Perlick BBS60 - Page 15

Back Bar Service Manual
Return to Table of Contents Troubleshooting Guide - Doors, Draws and Shelving Page 5-1
5.0 Troubleshooting Guide – Doors, Drawers and Shelving
PROBLEM
CAUSE
SOLUTION
Key won’t come out
after door is locked.
Key not in proper position.
Rotate key to the proper position and
remove.
Sliding doors not
closing.
Replace spring and/or torpedo assembly.
Refer to Section 8.4.3.
Hinge problems, door
falling off.
Improper door mounting
Verify proper mounting. Refer to
Section 8-4.
Excessive wear
Replace worn parts.
Refer to Section 8-4.
Door handles falling off
Improper handle mounting
Verify proper mounting. Refer to diagram.
Excessive wear
Replace worn parts. Refer to diagram.
Condensation on glass
doors.
High ambient temperature, high humidity
and environmental conditions.
Refer to Section 6.7.
Frequent door/drawer opening.
Refer to Section 8.1.
Cabinet temperature too low.
Adjust temperature. Refer to Table 7-4.
Factory Temperature Settings.
Sliding doors dragging
or binding
Debris in track.
Remove doors
Clean tracks and lube with NSF
approved food grade lube.