Perma PRO 250 - Page 70

permaPRO/PROCMP-2 -1-
Determine Discharge Period
Delivery / Content
 Checkthelubricationspecificationsofyourapplicationforthecorrectdischargeamountandtimesper
 lubricationpointthatthePRO/PROCMP-2distributoroutletshoulddischarge.Ifnecessary,calculatethis
 amountincm
3
per100operatinghours.
 Doublethisguretogetthetotallubricantamountincm
3
for100operatinghours(twolubricationpointsreceive
 thesameamountoflubricant).
 GotothechartinthePRO/PROCoperatingmanual(chapter6.7).Findyourpreviouslydeterminedtotal
 lubricantamountinthechart.Thechartwilltellyouthecorrectlubricatorsettingdependingonthesizeofthe
 PROLCunit.
 Calculation example:
 Lubricationdatalistedonthespecicationplateofanelectricmotor:
 150 cm
3
/ 4000 h lubricant per bearing(2bearings!)
 Thisamountsto3.75 cm
3
per 100 operating hours.
 EachoutletofthedistributorPRO/PROCMP-2mustdischarge3.75cm
3
per100hours.
 Totaldischargeamountthatthelubricationsystemmustdischarge:
 7.5 cm
3
per 100 operating hours(3.75cm
3
times2outlets/100h)
 Thechartonchapter6.7ofthePRO/PROCoperatingmanualshowsthefollowingsetting:
 20 weeksdischargewithlubricantcartridgePRO LC 250or
9 monthsdischargewithcartridgePRO LC 500
1
2
3
1
2
3
Amount Part name Part no. Part
1
2
2
1
1
PRO MP-2 Basic system
-PRODrivewithPROMP-2Distributor.............................................
-PROMP-2AccessoryBox:
TubeconnectorG1/8ofortubeoØ8mm90°-rotarytype..............
TubeConnectorG1/8afortubeaØ8mmstraight...........................
-PROMountingDevice......................................................................
-PROBatteryB.................................................................................
106908
.......................................................
.......................................................
.......................................................
.......................................................
............Notshowninpicture..........
1
2
2
1
1
PRO C MP-2 Basic system
-PROCDrivewithPROCMP-2Distributor.....................................
-PROMP-2AccessoryBox:
TubeconnectorG1/8ofortubeoØ8mm90°-rotarytype..............
TubeConnectorG1/8afortubeaØ8mmstraight...........................
-PROMountingDevice......................................................................
-PROCM12Cable5m....................................................................
106910
............Notshowninpicture..........
.......................................................
.......................................................
.......................................................
............Notshowninpicture..........
Following parts must also be ordered for a complete system: 
1
1
PROLC250

PROCoverforLC250
PROLC500

PROCoverforLC500
onrequest
106959
onrequest
106960
Tubeblackupto+80°CoØ8mmxiØ5mm-forPROpermeter
(pleasestatedesiredlengthonyourorder)
101569
....
....
....
....
....
....
....
3
4
5
3
5
1
2
4
6