Polaris 2007 Two Stroke User Manual

3.4
MAINTENANCE
Exhaust
Retaining
Springs
II I I
BRAKES
Hose Routing II I I
Hose Condition II I I
Fluid Leaks II I I
Brake Pads II I I
Brake Disc II I I
Parking Brakes IIIII
Brake System I
Brake Fluid R
FUEL MANAGEMENT
Pilot Air Screws II I
Carburetor
(synchronize)
II I
Idle RPM II I
Throttle Lever II I I I
Oil Pump Lever
(synchronize)
II I
Throttle Cable LL L
Choke Cable LL L
Choke II I
Vent Lines II I I
Throttle Position
Sensor
II I
Fuel Lines II I I I
Fuel Filter (Carb) R
Fuel Filter (CFI) RR
Oil Filter RR
Oil Lines II I
Air Box II I I I
Drain and Water
Traps
II I
ELECTRICAL
Auxiliary Shut-
Off Switch
III I I I
Throttle Safety
Switch
III I I I
Ignition Switch III I I I
Taillight III I I I
Brakelight III I I I
Headlight III I I I
Tether Switch
and Strap
III I I I
CHASSIS
Ski Toe
Alignment
II I
ITEM
PRE-
R
IDE
FREQUENCY MILES (KM)
PRE-
SEASON
150
(240)
500
(240)
1000
(1600)
2000
(3200)
I:INSPECT (CLEAN, ADJUST, TIGHTEN, LUBRICATE, REPLACE IF
NECESSARY) C:CLEAN R:REPLACE L:LUBRICATE
Suspension
Mounting Bolts
III I I I
Steering
Fasteners
II I I C
Rear Suspension
Fasteners
II I I I
Suspension
Shock Oil
II I I
Cooling Fins and
Shroud
II I I
Drive Shaft
Bearing
LL L I
Jackshaft
Bearings
LL L I
Skags (Wear
Bars)
III I I I
Ski Saddle/
Spindle Bolts
III I I I
Drive Chain
Tension
II I I I
Hood Straps III I I I
Seat Latches I
Rear Wheel Idler
Bolts
III I I I
Idler Bolt Jam
Nut
II I I I
Rear Suspension
Pivot Shafts
LL L
Handle Bar U-
Joint
LL L
Camber
Alignment
II I
Handlebar
Centering
I
Track Alignment III I I I
Track Tension II I I I
Rail Slide
Condition
II
Chaincase Oil II I I R I
Injection Oil
Level
I
ITEM
PRE-
R
IDE
FREQUENCY MILES (KM)
PRE-
SEASON
150
(240)
500
(240)
1000
(1600)
2000
(3200)
I:INSPECT (CLEAN, ADJUST, TIGHTEN, LUBRICATE, REPLACE IF
NECESSARY) C:CLEAN R:REPLACE L:LUBRICATE

Polaris 2007 Two Stroke Specifications

General

Brand	Polaris
Model	2007 Two Stroke
Category	Snowmobiles
Language	English