PS Engineering PMA8000G - Default Chapter; Table of Contents

Table of Contents
Section I – GENERAL INFORMATION ............................................................................... 1-1
1.1 INTRODUCTION...................................................................................................................................................................1-1
1.2 SCOPE.....................................................................................................................................................................................1-1
1.3 EQUIPMENT DESCRIPTION..............................................................................................................................................1-1
1.4 APPROVAL BASIS................................................................................................................................................................1-2
1.5 SPECIFICATIONS.................................................................................................................................................................1-2
1.6 EQUIPMENT SUPPLIED......................................................................................................................................................1-4
1.7 EQUIPMENT REQUIRED BUT NOT SUPPLIED .............................................................................................................1-4
1.8 LICENSE REQUIREMENTS................................................................................................................................................1-4
Section II - INSTALLATION ............................................................................... 2-1
2.1 GENERAL INFORMATION ................................................................................................................................................2-1
2.1.1 SCOPE ............................................................................................................................................................ 2-1
2.1.2 CERTIFICATION REQUIREMENTS........................................................................................................................ 2-1
2.2 UNPACKING AND PRELIMINARY INSPECTION.........................................................................................................................2-1
2.3 EQUIPMENT INSTALLATION PROCEDURES .............................................................................................................................2-1
2.3.1 COOLING REQUIREMENTS .................................................................................................................................2-1
2.3.2 MOUNTING REQUIREMENTS .............................................................................................................................. 2-1
2.3.3 AUDIO PANEL MOUNTING RACK INSTALLATION ...............................................................................................2-1
2.3.4 AUDIO PANEL TRAY AND CONNECTOR ASSEMBLY ............................................................................................2-2
2.4 CABLE HARNESS WIRING........................................................................................................................................................2-2
2.4.1 ELECTRICAL NOISE...........................................................................................................................................2-2
2.4.2 EXISTING GMA340 INSTALLATION...................................................................................................................2-3
2.4.3 HEADPHONE WIRING ........................................................................................................................................2-3
2.4.4 POWER ............................................................................................................................................................. 2-3
2.4.5 COMMUNICATIONS PUSH-TO-TALK ................................................................................................................... 2-3
2.4.6 AUDIO PANEL INTERFACE .................................................................................................................................2-3
2.4.7 TRANSMIT INTERLOCK......................................................................................................................................2-4
2.4.8 BACKLIGHTING.................................................................................................................................................2-4
2.4.9 UNSWITCHED INPUTS ........................................................................................................................................2-4
2.4.10 "SWAP" BUTTON FUNCTIONS.......................................................................................................................... 2-5
2.4.11 TEL (DUPLEX) FUNCTION FOR WIRED SATELLITE OR CELL PHONES................................................................ 2-5
2.4.12 PUBLIC ADDRESS MODE.................................................................................................................................2-6
2.4.13 PA MUTE (J2, PIN 12)....................................................................................................................................2-6
2.4.14 MISCELLANEOUS LOGIC OUTPUT (J2, PIN 18).................................................................................................2-6
2.4.15 CVR OUTPUT (J2, PIN 29) (SERIAL NUMBER F1256 AND ABOVE ONLY).......................................................... 2-6
2.5 FLIGHTMATE® CONNECTIONS ................................................................................................................................................2-6
2.5.1 MESSAGE TRIGGERS:.........................................................................................................................................2-6
2.5.2 STORING MESSAGES: ........................................................................................................................................2-7
2.6 INTERCOM WIRING ..................................................................................................................................................................2-7
2.6.1 ENTERTAINMENT INPUTS ..................................................................................................................................2-8
2.6.2 MUSIC DISTRIBUTION (DISTR) ........................................................................................................................ 2-8
2.6.3 ENTERTAINMENT MUTING .................................................................................................................................2-8
2.6.4 MUSIC CONFIGURATION ...................................................................................................................................2-9
2.6.5 DIGITAL RECORDER & FLIGHTMATE® PLAY BACK FEATURE ............................................................................2-9
2.7 MARKER BEACON INSTALLATION ..........................................................................................................................................2-9
2.7.1 MARKER ANTENNA INSTALLATION ...................................................................................................................2-9
2.7.2 EXTERNAL MARKER LIGHTS............................................................................................................................. 2-9
2.7.3 MIDDLE MARKER SENSE.................................................................................................................................2-10
2.8 ADJUSTMENTS........................................................................................................................................................................2-10
2.8.1 BACKLIGHT ADJUSTMENTS, (SERIAL NUMBER F01256 AND ABOVE) ............................................................... 2-10
2.9 COMMUNICATIONS ANTENNA INSTALLATION NOTES .........................................................................................................2-11
2.10 PMA8000G PIN ASSIGNMENTS...........................................................................................................................................2-12
2.11 WIRING CHECKOUT ............................................................................................................................................................2-12
2.12 UNIT INSTALLATION ...........................................................................................................................................................2-13
2.13 OPERATIONAL CHECKOUT .................................................................................................................................................2-13
2.13.1 REQUIRED TEST EQUIPMENT ........................................................................................................................ 2-13
2.13.2 AUDIO PANEL TEST...................................................................................................................................... 2-13
2.13.3 MARKER CHECKOUT ....................................................................................................................................2-14
2.13.4 BLUETOOTH CHECKOUT ............................................................................................................................... 2-14
2.13.5 INTERNAL RECORDER CHECKOUT- PLAYBACK ......................................................................................... 2-14
2.14 FINAL INSPECTION ..............................................................................................................................................................2-14
Section III OPERATION ............................................................................... 3-1
3.1 SCOPE.....................................................................................................................................................................................3-1