Red Jacket Quick-Set P75S1T2 - Default Chapter; Table of Contents

Table of Contents
iii
Introduction
Safety Precautions ............................................................................................................1
Warnings and Instructions ................................................................................................2
Important Safety Information ....................................................................................2
Preliminary Precautions............................................................................................2
Requirements For Use .............................................................................................3
Operating Precautions..............................................................................................3
Fuel Compatibilities ..........................................................................................................4
Leak Detector Installation and Manifold Dimensions ........................................................4
Recommended Floating Suction Installation .....................................................................6
Dimensions for Pump Selection ........................................................................................7
Specifications ....................................................................................................................8
Installation
Attaching the UMP ..........................................................................................................13
Installing the Pump .........................................................................................................15
Conduit Box Wiring .........................................................................................................18
For three Phase Pumps (Without Capacitor)..........................................................18
Installing Two Pumps for Tandem Operation ..................................................................24
Wiring Single-Phase Tandem Pumps .............................................................................25
Wiring Three Phase Tandem Pumps ..............................................................................26
Adjusting the Functional Element ...................................................................................27
To Adjust the Relief Pressure.................................................................................27
Initial Start Up of Pump ...................................................................................................28
NOTE: For Three Phase Pumps Only!...................................................................28
Testing The Installation
To Test Piping .................................................................................................................30
To Test Tank ...................................................................................................................31
Service And Repair
Removing the Pump .......................................................................................................32
Replacing the UMP .........................................................................................................33
Replacing the Functional Element ..................................................................................35
Disable the Pump ...................................................................................................35
Replace the Functional Element.............................................................................35
Replacing the Capacitor in Packer .................................................................................36
Installing a Replacement Extractable Pump ...................................................................37
Parts Lists
Customer Service Number ..............................................................................................40
Yoke Assembly and Conduit Box Parts ..........................................................................40
Packer-Manifold Assembly Parts ....................................................................................41
Pump Parts .....................................................................................................................43
Control Boxes .................................................................................................................46
Appendix A: 4” Standard Red Jacket STP Safety Instructions
Appendix B: Declaration of Conformity
Appendix C: FDNY Conditions of Approval