Ski-Doo REV G4 Trail/Crossover E-TEC Series User Manual

Name: Ski-Doo REV G4 Trail/Crossover E-TEC Series
Brand: Ski-Doo
Rating: 4 (1 reviews)

291 pages

To Next Page

To Previous Page

BASIC PROCEDURES

119

520001663-012_b

1. Rope crossed

2. Rope to be winded

3. Rope end

Wind rope two turns counterclockwise tightly around the drive

pulley where shown.

Pull the rope using a sharp, crisp pull so the rope comes free

of the drive pulley.

Table of Contents5
General Information11
Foreword12
Know before You Go12
Safety Messages13
About this Operator's Guide13
Safety Information15
General Precautions16
Avoid Carbon Monoxide Poisoning16
Avoid Gasoline Fires and Other Hazards16
Avoid Burns from Hot Parts17
Accessories and Modifications17
Special Safety Messages18
Riding the Vehicle23
How to Ride23
Carrying a Passenger28
Terrain/Riding Variations30
Environment37
Traction Enhancing Products40
Manoeuvrability41
Acceleration43
Braking43
Important Safety Rules44
Effects of Having a Studded Track on the Life of the Snowmobile44
Installation of Studs on BRP Approved Tracks45
Maintenance/Replacement47
Safety Information on the Vehicle49
Hang Tag(S)49
Vehicle Safety Labels51
Technical Information Labels60
Controls, Instruments and Equipment64
Handlebar65
Throttle Lever65
Brake Lever66
Parking Brake Lever66
Engine Cut-Off Switch (D.E.S.S. Post)68
Emergency Engine Stop Switch69
Adjustable Handlebar Riser (if Equipped)71
Handlebar Multifunction Switch72
Seat77
10) Front and Rear Bumpers79
11) Gauge80
12) Storage Compartments96
13) Operator's Guide97
14) Tools97
15) Drive Belt Guard100
16) Spare Drive Belt Holder103
Upper Body Module (Hood)105
18) Side Panels110
Rewind Starter Handle (if Equipped)112
Heated Seats Switch (on Applicable Models)112
Fuel113
Fuel Requirements113
Vehicle Fueling Procedure115
Injection Oil117
Recommended Injection Oil117
Injection Oil Level Verification117
Break-In Period120
Operation During Break-In120
Basic Procedures121
Engine Starting Procedure121
Emergency Starting121
Vehicle Warm-Up124
Reverse (RER)125
Shutting off the Engine126
Riding Conditions and Your Snowmobile128
Altitude128
Temperature128
Special Operation129
Towing an Accessory129
Towing Another Snowmobile129
Tune Your Ride130
Ski Runner Depth Setting (Pilot TS Skis)131
Rear Suspension Adjustments132
Front Suspension Adjustments158
Adjustment Tips According to Vehicle Behavior166
Vehicle Transportation168
Pre-Ride Inspection169
Pre-Ride Inspection170
Before Starting the Engine170
After Engine Is Started171
Pre-Ride Check List171
Maintenance173
Maintenance Schedule174
Maintenance Procedures177
Engine Coolant177
Exhaust System178
Spark Plugs179
Brake Fluid179
Chaincase Oil181
Drive Chain184
Drive Belt185
Drive Pulley191
Track195
Suspension204
Skis206
Fuses206
Headlights208
Removing Battery211
Installing Battery213
Vehicle Care215
Post-Operation Care215
Vehicle Cleaning and Protection215
Storage217
Engine Storage Mode217
Technical Information221
Vehicle Identification222
Vehicle Description Decal222
Identification Numbers222
Vehicle Compliance Labels226
EPA Compliance Label226
SSCC Label226
Noise Emission and Vibration Values228
States)228
Ec Declaration of Conformity229
Eac Declaration of Conformity230
Epa Certified Engines231
Engine Emissions Information231
Radio Frequency Digitally Encoded Security System (Rf D.e.s.s. Key)233
Specifications - Engine234
Specifications - Vehicle237
Trouble-Shooting247
Troubleshooting Guidelines248
Monitoring System251
Pilot Lamps, Messages and Beeper Codes251
Fault Codes255
Warranty257
Brp Limited Warranty Usa and Canada: 2020 Ski-Doo ® Snowmobiles258
Scope of the Limited Warranty258
Limitations of Liability258
Exclusions - Are Not Warranted259
Warranty Coverage Period259
Conditions Required for Warranty Coverage260
What to Do to Obtain Warranty Coverage261
What Brp will Do261
Transfer261
Consumer Assistance262
Epa Emission-Related Warranty263
Emission-Related Warranty Period264
Components Covered264
Limited Applicability265
Brp International Limited Warranty: 2020 Ski-Doo ® Snowmobiles266
Scope of the Limited Warranty266
Limitations of Liability266
Exclusions - Are Not Warranted267
Warranty Coverage Period268
Conditions to Have Warranty Coverage269
What to Do to Obtain Warranty Coverage269
What Brp will Do270
Transfer270
Consumer Assistance271
Brp Limited Warranty for the European and the Commonwealth of the Independent States (Cis) Areas and Turkey: 2020 Ski-Doo ® Snowmobiles272
Scope of the Limited Warranty272
Limitations of Liability272
Exclusions - Are Not Warranted273
Warranty Coverage Period274
Conditions to Have Warranty Coverage275
What to Do to Obtain Warranty Coverage275
What Brp will Do276
Transfer276
Consumer Assistance277
Customer Information279
Privacy Information280
Contact Us281
Asia281
Europe281
North America282
Oceania282
South America283
Change of Address/Ownership284

Ski-Doo REV G4 Trail/Crossover E-TEC Series User Manual

Table of Contents

Questions and Answers:

Ski-Doo REV G4 Trail/Crossover E-TEC Series Specifications

Related product manuals

Brand	Ski-Doo
Model	REV G4 Trail/Crossover E-TEC Series
Category	Snowmobiles
Language	English