ZB2044December 2007
Page 29
TM
Section 2 - Operation Visual and Daily Maintenance Inspections
• Batteries
Proper battery condition is essential to good
engine performance and operational safety.
Improper uid levels or damaged cables and
connections can result in engine component
damage and hazardous conditions.
WARNING
Explosion hazard. Keep ames
and sparks away. Do not smoke
near batteries.
WARNING
Battery acid is extremely corrosive -
Wear proper eye and facial protection as
well as appropriate protective clothing.
If contact occurs, immediately ush with
cold water and seek medical attention.
1. Check batteries case for damage.
2. Clean terminals and cable ends thoroughly
with a terminal cleaning tool or wire brush.
3. Ensure all connections are tight.
4. If applicable, check battery uid level. If plates
are not covered, add distilled or demineralized
water.
5. Replace batteries if damaged or incapable of
holding a lasting charge.
WARNING
Use original or manufacturer-approved
p a r t s an d c omp o n e nts f o r t he
telehandler.
• Engine Air Filter
- Ensure there are no loose or missing
parts and there is no visible damage.
- Ensure air cleaner vaccuator valve (if
applicable) is free from dirt or dust by
squeezing the valve lips.
• Engine Coolant
- The coolant level should be between
the minimum and maximum marks.
Add coolant as needed. Refer to your
engine manual for recommended coolant
mixture. Refer to Section 2.17 for coolant
level maintenance.
• Muffler and Exhaust
- Ensure mufer and exhaust systems are
properly secured, with no evidence of
damage.
Exhaust
System
Rear
Door
Standard
Batteries
Rear side View
To order go to Discount-Equipment.com
To Next Page
Loading...
