Skyjack ZB2044 - 2.8-8 Engine Compartment Checks; Fuel Leak Inspection

Page 30 December 2007
ZB2044
Visual and Daily Maintenance Inspections Section 2 - Operation
2.8-8 Engine Compartment
- Ensure compartment cover is secure and in
proper working order.
• Engine Oil Level
- Maintaining the engine components
is essential to good performance and
service life of the telehandler.
WARNING
Beware of hot engine components.
Check oil level on dipstick
- Oil level should be in the “safe” zone.
Add oil as needed. Refer to Table 2.4 for
recommended oil type.
• Fuel Leaks
Failure to detect and correct fuel leaks will
result in an unsafe condition. An explosion or
fuel re may cause death or serious injury.
DANGER
Engine fuels are combustible. Inspect
the telehandler in an open, well-
ventilated area away from heaters,
sparks and flames. Always have an
approved re extinguisher within easy
reach.
Perform a visual inspection around the following
areas:
• hoses and ttings
• fuel pump
• fuel lter
• fuel tank
• Hydraulic Pumps
- Ensure there are no loose or missing
parts and there is no visible damage.
- Ensure all bolts are properly tightened.
- Ensure all ttings and hoses are properly
tightened and there is no evidence of
hydraulic oil leakage.
• Belts
- Ensure belts are in good working
condition and have correct tension.
Replace if belts are cracked, frayed, or
have chunks of material missing. Refer to
engine manufacturer’s manual for proper
replacement procedure.
Engine
Compartment
Rear Axle
& Tire
Exhaust
To order go to Discount-Equipment.com