2
GRASS COLLECTION SYSTEM
TABLE OF CONTENTS
Description - - - - - - - - - - - - - - - - - - - - - - - - - - - - 5
Main Frame Assy Installation - - - - - - - - - - - - - - - - 13
Mount Arm/Tube Assy Installation - - - - - - - - - - - - - - 11
PTO Drive Assy - - - - - - - - - - - - - - - - - - - - - - - 14-15
I INTRODUCTION AND DESCRIPTION - - - - - - - - - - - - 5
Drive Assy & Belt Installation - - - - - - - - - - - - - - - - 16
Left Mount Plate Installation - - - - - - - - - - - - - - - - - -7
Boot Kit Installation- - - - - - - - - - - - - - - - - - - - - - - 17
Lift Handle Installation - - - - - - - - - - - - - - - - - - - - - 18
SECTION PAGE
Right Mount Plate Installation - - - - - - - - - - - - - - - - -8
II INSTALLATION FOR USE - - - - - - - - - - - - - - - - - - - - - 6
Safety - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - 2
Warranty - - - - - - - - - - - - - - - - - - - - - - - - - - - - - 4
Introduction- - - - - - - - - - - - - - - - - - - - - - - - - - - - 5
Preparation Of Mower - - - - - - - - - - - - - - - - - - - - - 6
Rear Mount Plate Installation - - - - - - - - - - - - - - - - -9
PTO Mount Plate Installation - - - - - - - - - - - - - - - - - 10
Safety Alert Symbols- - - - - - - - - - - - - - - - - - - - - - 3
Main Frame Mount Installation - - - - - - - - - - - - - - - 12
Aluminum Box Assy Installation - - - - - - - - - - - - - - 19
Inlet, Inlet Ring & Debris Deflector Installation - - - - - 20
Dump Mechanism Adjustment- - - - - - - - - - - - - - - - 19
IV MAINTENANCE - - - - - - - - - - - - - - - - - - - - - - - - - - 38-39
Overall Parts List - - - - - - - - - - - - - - - - - - - - - - - - 36
General Safety - - - - - - - - - - - - - - - - - - - - - - - - - 38
Disengagement Of The PTO Assembly- - - - - - - - - - 38
Operation & Tips On Mowing - - - - - - - - - - - - - - - - 38
Maintenance Checklist - - - - - - - - - - - - - - - - - - - - 38
Unloading The Collection System - - - - - - - - - - - - - 38
Parts And Service Information- - - - - - - - - - - - - - - - 39
Torque Specifications - - - - - - - - - - - - - - - - - - - - - 40
Lubrication - - - - - - - - - - - - - - - - - - - - - - - - - - - - 39
Troubleshooting - - - - - - - - - - - - - - - - - - - - - - - - - 41
Safety Decals - - - - - - - - - - - - - - - - - - - - - - - - - - 37
V PARTS AND SERVICE - - - - - - - - - - - - - - - - - - - - - - - 39
Exploded Views & Parts List - - - - - - - - - - - - - - - 27-35
III OPERATING INSTRUCTIONS - - - - - - - - - - - - - - - - - - 38
Lower Hose To Boot Installation - - - - - - - - - - - - - - 23
Impeller Blade Removal/Replacement - - - - - - - - - - 24
Weight Kit Installation - - - - - - - - - - - - - - - - - - - 25-26
Wiring Harness Installation- - - - - - - - - - - - - - - - 21-22
Length of Hose Adjustment - - - - - - - - - - - - - - - - - -23
SECTION PAGE
Lower Hose To Blower Cone Installation - - - - - - - - - 23
Upper Hose Installation - - - - - - - - - - - - - - - - - - - - -23
SAFETY
1. Read the operator’s manual carefully and familiarize yourself with the proper use of your attachment. Do not allow
anyone who is not acquainted with the Safety Instructions to use your attachment.
9. Mow across the face of slopes (not more than 10 degrees); never up and down the face.
3. Do not allow children to operate the machine. Do not allow adults to operate it without proper instruction.
you.
8. Stop machine, shut off deck attachment, set parking brake, shut off engine and remove ignition key before
4. Be especially watchful of children and pets entering into the area while operating.
2. Know the controls and how to stop them quickly. READ THE OPERATOR’S MANUAL!
5. Keep your eyes and mind on your machine while mowing or operating your attachment. Don’t let others distract
6. Do not attempt to operate your machine when not in the driver’s seat.
7. Always shut off blades and engine when emptying the container.
removing clogs, removing or replacing hose, boot, blower cone, or performing any maintenance.
11. Inspect your lawn and remove any foreign objects before mowing. Never deliberately run the mower across any
foreign object.
10. It is recommended that the container be emptied when half full while operating on slopes. Start mowing on slopes
13. Wear eye protection to prevent debris from getting into your eyes.
when the container is empty.
12. Wear hearing protection.
2017 (v1.0)
To Next Page
Loading...
Need help?
General