Toshiba HFCR407C User Manual

176 pages

To Next Page

To Next Page

To Previous Page

To Previous Page

Page #2 background image

Loading...

Page #2 background image

2

Table of Contents

Table of Contents3
Precautions for R407C Outdoor Units5
Introduction5
- Avoid Installation in the Following Locations:5
- Precautions5
- Precautions for R-407C Outdoor Units6
- Liquid Receiver Fusible Plug6
- System Pressure Measurement6
- Explanation of Toshiba Serial Number6
- Components7
- Outdoor Unit7
- Branching Joints/Headers7
- Operating Conditions8
- Outdoor Temperature8
- Room Temperature8
Summary8
- Mode Priority9
- Range of Combined Units9
- Restriction for Combination Units9
- Model Name9
- Branching10
Outline of MMS (Modular Multi System)10
Indoor Units12
Parts Specifications12
Outdoor Units13
Construction Views - Outdoor Units21
Built-In Duct22
Construction Views - Indoor Units22
- Built-In Slim Duct23
- Low Wall24
- Chassis25
- Ceiling26
- High Wall27
- 2-Way Cassette28
- 4-Way Cassette29
- Inverter Unit (10 HP, 8 HP)31
Wiring Diagrams31
- Fixed-Speed Unit (10 HP, 8 HP)32
- Fixed-Speed Unit (6 HP)33
- Inverter Unit (10 HP, 8 HP) Cooling Only34
- Fixed-Speed Unit (10 HP, 8 HP) Cooling Only35
- Wiring Diagrams36
- Wall Unit38
- Inverter Unit (10 HP, 8 HP) Heat Pump44
- Model MM-A0280HT, MM-A0224HT44
Refrigerant Piping Systematic Drawings44
- Model MM-A0280HX, MM-A0224HX45
- Model MM-A0160HX, MM-A0160CX46
- Fixed-Speed Unit (6 HP) Heat Pump46
- Model MM-A0280CT, MM-A0224CT47
- Model MM-A0280CX, MM-A0224CX48
- Normal Operation-Heat Pump System49
- Cooling Mode49
Combined Refrigerant Piping Systematic Drawings49
- Emergency Operation When Inverter Unit Has Failed50
- Heat Pump System (Master Unit Back-Up Operation: Cooling Mode)50
- Heat Pump System (Cooling Mode)51
- Combined Refrigerant Piping Systematic Drawings52
- Recovery of Refrigerant in Failed Outdoor Unit52
- Heat Pump System (Normal Outdoor Unit Refrigerant Recovery)52
- Refrigeration Cycle Schematic53
Refrigerant Cycle Schematic - Indoor Units53
- Thermostat On/Thermostat off54
- Outdoor Unit54
- Operation Start/Operation End54
Outline of Control54
- Electronic Expansion Valve (PMV) Control55
- Pulse Motor Valve (PMV) Control55
- Outdoor Fan Control55
- Capacity Calculation56
- Oil Level Valve Detection Control56
- Oil Equalizing this Control57
- Refrigerant/Oil Recovery Control57
- Release Valve Control58
- Fixed-Speed Compressor High Pressure Release Control58
- Compressor Winding Heating Control59
- Crank Case Heater Control59
- IPDU (Inverter) Control60
- Defrost Control (Reverse Defrost Method)61
- Cold Draught Prevention Control62
- IDU Exchanger Heat Removal62
- PMV (Pulse Motor Valve)63
- Cooling Operation in Low Ambient Temperature63
- Other Cautions63
- System Information Data Display (Displayed on the Inverter Unit Only)67
Self Diagnostic Display Information67
- Outdoor Unit Information Data Display (Displayed on each Outdoor Unit)68
- Outdoor Cycle Data Display (Displayed on each Outdoor Unit)69
- Outdoor Unit Information Data Display (Displayed on Inverter Unit Only)70
- LED Display on Indoor PC Board-MCC-1361-0171
- General Type71
- Indoor PC Board Parts Layout71
Control Circuit Configuration71
- Display on Remote Controller72
- Indoor PMV Full Open/Full Close Function72
- Switch Positions at Shipment from the Factory73
- Contents of Switch Set-Up74
- Jumper Set-Up75
- Service PC Board Selection Corresponded Table MCC-1361-0175
- Switch Set-Up75
- LCD Display76
- Remote Controller Check Display76
- Operating and Reading the Check Display76
Troubleshooting76
- 7 Segment Display77
- Filter Data77
- Check Data77
- Self Diagnostic Function78
- Diagnostic Procedure for Check Code79
- [04] Inverter Serial Signal Short Circuit79
- [0B] Drain Pump Fault80
- [0C] Indoor Sensor (TA) Short or Open Circuit Alarm80
- [11] Indoor Fan Motor Short Circuit Alarm81
- [12] Indoor PC Board Short Circuit Alarm81
- [14] G-Tr Short Circuit Protective Operation Alarm (Gate Transistor)82
- [1C] Extension IC, EEPROM Short Circuit Alarm83
- [17] Current Detection Circuit Alarm83
- [18] Outdoor Heat Exchanger Sensor (TE) Short Circuit83
- [1D] Compressor Error Alarm84
- [1F] Compressor Break down85
- [21] Inverter High Pressure SW Circuit Alarm86
- [22] High Pressure Protective Operation87
- [87] Missing Phase88
- Modify the Power Source Wiring88
- [89] Indoor over Capacity88
- [8D] Reduction in the No. of Connected Outdoor Units89
- [8E] Outdoor Unit Connection over Limit89
- [8F] Server Outdoor Address Incorrect90
- [93] Indoor TC1 Sensor Short Circuit Alarm90
- [94] Indoor TC2 Sensor Short Circuit Alarm90
- [95] Indoor/Outdoor Comunication Short Circuit91
- [96] No. of Connected Indoor Units over Capacity92
- [97] Central Management Communication Short Circuit93
- [98] Central Management Address Set-Up Fault94
- [99] Remote Controller Serial Signal Circuit Alarm95
- [9A] Indoor Unit Miswiring/Misconnection96
- [9F] Refrigerant Circulation Amount Shortage Judgement96
- [A0] Discharge Temp. Sensor (TD1) Short Circuit97
- [A2] Suction Temp. Sensor (TS) Short Circuit97
- [A1] Discharge Temp. Sensor (TD2) Short Circuit97
- [A6] Discharge Temperature TD1 Alarm98
- [A7] Suction Temperature (TS) Alarm99
- [AA] High Pressure Sensor (Pd) Short Circuit99
- [Ab] Pressure Sensor (Pd/Ps) Miswiring100
- [AE] Low Hz Time Discharge Temp. (TD1) Alarm101
- [AF] Outdoor Unit Power Source Phase Order Miswiring101
- [B9] Indoor Pressure Sensor Short Circuit102
- [B4] Low Pressure Sensor (Ps) Short Circuit102
- [Bb] Discharge Temperature (TD2) Alarm103
- [Bd] Mg-SW Protective Operation104
- [Be] Low Pressure (Ps) Protective Operation105
- [D1] Master Outdoor Unit Set-Up Alarm106
- [D2] Slave Outdoor Unit Alarm107
- [D3] TH Sensor Alarm107
- [D4] Oil Temp. (TK1) Sensor Alarm107
- [D5] Oil Temp. (TK2) Sensor Alarm107
- [D7] Low Oil Level Detection108
- 2-Way Valve Leakage/Blockage Check Procedure109
- Blockage Check Procedure for Oil Return Circuit of Oil Separator109
- [D8] Oil Temperature (TK1) Detection Alarm109
- [D9] Oil Temperature (TK2) Detection Alarm110
- Oil Tank Peripheral Circuit Leakage/Blockage Check Procedure111
- [Da] Abnormal Overheat of Heat Sink112
- SV3C Valve Blockage Check Procedure113
- [Db] SV3C Valve Blockage Detection113
- [DC] SV3C Valve Leakage Detection114
- SV3C Valve Leakage Check Procedure114
- [DD] Outdoor PMV Refrigerant Leakage Detection115
- [De] Indoor Address Undefined116
- [Df] Outdoor Address Undefined116
- [E1] Fixed-Speed (1) High Pressure SW System Alarm117
- [F0] Fixed-Speed (2) High Pressure SW System Alarm117
- [E5] Inverter IOL Short Circuit118
- [E6] Fixed-Speed (1) IOL, OCR Alarm119
- [F1] Fixed-Speed (2) IOL, OCR Alarm119
- Segment Display Function120
- Outdoor Unit 7 Segment Display (Interface PC Board)120
- When the System Has Stopped Due to an Error of the Outdoor Unit, Check the Following Items120
- Description of Functional Parts121
- When an Outdoor Unit Has Failed122
- Emergency Operation122
- When One Compressor Has Failed (Back-Up Set-Up of Compressor)122
Back-Up Operation122
- Fault in Fixed-Speed Unit (Back-Up of Slave Outdoor Unit)123
- Fault of Inverter Unit (Back-Up Set-Up of Master Outdoor Unit)124
- Outdoor Back-Up Set-Up in Cooling Season (Simple Setting Method)125
- Oil Tank Circuit System Error126
- Oil Level Judgement Result126
- Peripheral Circuits of Oil Tank126
Forced Function of Oil Level Detection126
Leak Test127
Refrigerant Pipe Installation127
- Vacuuming128
- Charging the System with Additional Refrigerant129
- Calculating the Amount of Additional Refrigerant Required129
- Refrigerant in the System When Shipped from the Factory129
- Additional Refrigerant Charging Method130
- Additional Refrigerant Charging Amount Reference Chart131
- Procedure and Summary of Trial Operation132
- Check before Trial Operation132
- Trial Operation Check133
- Flowchart of Trial Operation Procedure133
- Power Source and Initial Set-Up Check133
- Fan Operation Check133
- Cooling Operation Check134
- Criteria for Indoor Air Inlet/Outlet Temperature Difference135
- Criteria of Operation Current Value135
- Criteria of Operation Pressure135
- Automatic Address (between Outdoor Unit and Indoor Unit)136
- Cautions During Automatic Addressing136
- Service Support Function137
- Check Function for Connection of Refrigerant Pipe and Control Transmission Line137
- Function to Start/Stop (On/Off) Indoor Unit from Outdoor Unit138
- Trial Cooling Operation Function139
- Collective Start/Stop (On/Off) Function140
- Individual Start/Stop (On/Off) Function141
- Alarm Clear Function142
- Clearing of Check Code on Remote Controller142
- Clearing the Interface PC Board of the Inverter Outdoor Unit142
- Clearing of Check Code Alarm by Resetting Power Source143
- Remote Controller Identification Function143
- Identifying Procedure143
- Pulse Motor Valve (PMV) Manual “Full Open” Function in the Indoor Unit144
- Pulse Motor Valve (PMV) Forced Full Open/Full Close Function in Outdoor Unit144
- Refrigerant Recovery Method145
- Refrigerant Recovery Method for a Failed Outdoor Unit145
- When Back-Up Operation Has Not Been Utilised145
Replacing the Compressor145
- When Back-Up Operation Has Been Utilised146
- Position of Service Valve147
- Open/Close Direction of Service Valve147
- Explanatory Diagram: Modular Multi Service Valve147
- Compressor Replacement Procedure148
- Compressor Replacement Procedure149
- In Case of Removal of the Compressor from the Front Side149
- Outdoor Units (Inverter and Fixed-Speed Units)149
- Removing of Parts149
- Extraction of Oil from Compressor149
- Charging of Refrigerant150
- In Case of Removal of the Compressor from the Rear Side151
- Removing of Compressor152
- Replacing the Interface PC Board155
- MM-A0280Ht, Mma0280Hx, MM-A0280Ct, Mma0280Cx, MM-A0224Ht, Mma0224Hx, MM-A0224Ct, Mma0224Cx156
Exploded Views and Service Parts156
- MM-A0280Ht, MM-A0280Ct, MM-A0224Ht, MM-A0224Ct, MM-A0280Hx, MM-A0280Cx, MM-A0224Hx, MM-A0224Cx157
- MM-A0160Hx, MM-A0160Cx158
- MM-A0280Hx, MM-A0280Cx, MM-A0224Hx, MM-A0224Cx160
- Outdoor Unit Electrical Parts Assembly160
- MM-A0280Ht, MM-A0280Ct, MM-A0224Ht, MM-A0224Ct160
- MM-A0280Ht, MM-A0280Ct, MM-A0224Ht, MM-A0224Ct, MM-A0280Hx, MM-A0280Cx, MM-A0224Hx, MM-A0224Cx, MM-A0160Hx, MM-A0160Cx161
- Built-In Duct–MM-B056, MM-B080, MM-B112, MM-B140162
- Ceiling Type–MM-C042, MM-CR042, MM-C056, MM-CR056, MM-C080, MM-CR080, MM-C112, MM-CR112, MM-C140, MM-CR140163
- High Wall–MM-K042, MM-KR042, MM-K056, MM-KR056, MM-K080, MM-KR080164
- Chassis–MM-N028, MM-N042, MM-N056, MM-N080165
- Low Wall–MM-S056, MM-SR056, MM-S080, MM-SR080166
- Built-In Slim Duct–MM-SB028167
- 2-Way Cassette–MM-TU028, MM-TU042, MM-TU056168
- 4-Way Cassette–MM-U056, MM-U080169
- 4-Way Cassette–MM-U112, MM-U140170
- Ceiling Panel-RBC-U133PG(W)-PE171
- Ceiling Panel-RBC-U264PG(W)-E, RBC-U264PGR(W)-E172
- Ceiling Panel-RBC-U464PG(W)-E, RBC-U464PGR(W)-E173

Questions and Answers:

Need help?

Do you have a question about the Toshiba HFCR407C and is the answer not in the manual?

Toshiba HFCR407C Specifications

General

Brand	Toshiba
Model	HFCR407C
Category	Air Conditioner
Language	English

Related product manuals

Toshiba HFC R407C

Preview: Toshiba RAV-HM561UT-E

Toshiba RAV-HM561UT-E

Preview: Toshiba RAV-HM801FT-E

Toshiba RAV-HM801FT-E

Preview: Toshiba RAV-HM901FT-E

Toshiba RAV-HM901FT-E

Preview: Toshiba RAV-HM561FT-E

Toshiba RAV-HM561FT-E

Preview: Toshiba RAS-H10BKCV-M

Toshiba RAS-H10BKCV-M

Preview: Toshiba RAV-HM561UTP-E

Toshiba RAV-HM561UTP-E

Preview: Toshiba RAS-10N3KV-HK1

Toshiba RAS-10N3KV-HK1

Toshiba RAV-HM801BTP-E

Preview: Toshiba RAV-HM401CTP-E

Toshiba RAV-HM401CTP-E

Preview: Toshiba RAV-HM301KRTP-E

Toshiba RAV-HM301KRTP-E

Preview: Toshiba RAS-H10L4KCVG-V

Toshiba RAS-H10L4KCVG-V