Home
Xantrex
Controller
C35
Xantrex C35 User Manual
5
of 1
of 1 rating
114 pages
Give review
Manual
Specs
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
A
S
pecifi
cations
Appendix A,
“Specifications”
provide the
s
pecifi
cations
for
the
C
-Series
Multif
unction DC
Control
ler
.
Fo
r i
nformatio
n
on:
See:
“Ele
ctric
al Speci
ficat
ions”
pa
ge
70
“Featu
res and Opt
ions Spec
ifi
cati
ons”
page
71
“Envir
onm
ent
a
l
Spe
ci
fic
ations
”
page
72
88
90
Table of Contents
Default Chapter
4
Contact Information
4
About this Guide
5
Abbreviations and Acronyms
7
Related Information
7
General Safety Instructions
9
Important Safety Instructions
9
Table of Contents
13
Introduction
21
Features
22
Figure 1-1 C-Series Multifunction DC Charge Controllers
22
Operating Modes
23
Charge Control Mode
24
Three-Stage Battery Charging
24
Figure 1-2 3-Stage Battery Charging Process
25
Battery Temperature Compensation
26
Manual or Auto Equalization Charge
26
Load Control Mode
26
Controller Functions
27
Photovoltaic Charge Controller
27
Figure 1-3 PV Charge Controller
27
Automatic PV Array Night Disconnect
28
Diversion Controller
28
Diversion Loads
29
Figure 1-4 Diversion Controller
29
Load Controller
30
Figure 1-5 Load Controller
31
Low Voltage Disconnect
31
Low Voltage Reconnect
31
Optional Accessories
32
Figure 1-6 Decal Displaying Load Control Voltage Settings
32
Figure 1-7 Optional Accessories - CM/R, CM, and BTS
32
Installation
33
Pre-Installation
34
Removing the Top Cover
34
Removing Knockouts
34
Figure 2-1 Removing the Front Cover
34
Figure 2-2 C-Series Dimensions and Knockout Locations
35
Mounting the Controller
36
Configuring the C-Series Controller
38
Jumper Settings
38
Figure 2-4 Jumper Positions
38
Figure 2-5 Circuit Board Components
39
Table 2-1 Factory Default Settings for C-Series Controllers
39
Operating Mode Jumper
40
Voltage Jumper
40
Figure 2-6 Mode of Operation Jumper
40
Figure 2-7 Voltage Selection Jumper
40
Automatic/Manual Battery Equalization (EQ) and Low Voltage Reconnect (LVR) Jumper
41
Figure 2-8 EQ/LVR Jumper and Reset Switch
41
Chapter 2 Contains Information and Procedures to Install
42
Adjusting the C-Series Voltage Settings
42
Figure 2-9 Bulk and Float Charge Potentiometers (Pots)
42
Setting Voltage Parameters for Charge Control Mode
42
Figure 2-10 Bulk and Float Charge Settings for Charge/Diversion
43
Control Mode
43
Figure 2-11 Potentiometers with Decal for LVR and LVD Settings
44
Setting Voltage Parameters for Load Control Mode
44
Figure 2-12 LVR and LVD Settings for Load Control Mode
45
Figure 2-13 R46 Resistor Location
46
Setting Voltage Parameters Diversion Control Mode
46
Setting Voltage Parameters for Alkaline Batteries
46
Figure 2-14 Voltage Settings with R46 Resistor Clipped
47
Using a Digital Voltmeter to Adjust Voltage Settings
48
Figure 2-15 Test Points for Adjusting Voltage Using a DVM
49
Equalization Charging
50
Figure 2-16 Manual Equalization Settings
50
Figure 2-17 Front Panel LED and Reset Switch Location
51
Manual Equalization
51
Automatic Equalization
52
Figure 2-18 Auto Equalization Settings
52
Figure 2-19 Terminating the Equalization Charge
53
Temperature Compensation
53
Terminating the Equalization Process
53
Automatic Battery Temperature Compensation
54
Temperature Compensation Based on Battery Type
54
Table 2-2 Variances in Charging Voltage Based on Battery Temperature
55
Manual Battery Temperature Compensation
56
Figure 2-20 Grounding the
57
Grounding
57
DC Terminal Connector Locations
58
Wiring
58
Current Rating
59
Figure 2-21 DC Connection Terminals
59
Terminal Torque Requirements
59
Wire Size and Over-Current Protection Requirements
59
Figure 2-22 AWG Wire Gauge Reference Chart
60
Minimum Recommended Wire Gauge
60
Surge Protection
60
Over-Current Protection
61
Table 2-3 Minimum Wire Size
61
Long-Distance Wire Runs
62
Maximum One-Way Distance and Wire Size
62
Table 2-4 One-Way Wire Distance and Wire Size
63
PV Charge Control Mode Wiring
64
Figure 2-23 PV Charge Control Mode Wiring
65
Diversion Control Mode Wiring
66
Figure 2-24 Diversion Control Mode Wiring
67
DC Load Control Mode Wiring
68
Figure 2-25 Load Control Mode Wiring
69
Figure 2-26 Installing a Digital Display
70
Installing a Digital Display
70
Installing Optional Accessories
70
Figure 2-27 Installing the BTS
71
Installing the Battery Temperature Sensor
71
Figure 2-28 Re-Installing the CM Faceplate
72
Reinstalling the Faceplate
72
Chapter 3 Contains Information about the Operation of a
74
Basic Operation
74
Figure 3-1 C-Series Status LED and Reset Button Location
74
LED Status Indicator
75
Figure 3-2 C-Series Front Panel Label
75
Charge Control or Diversion Control
76
Charge Control or Diversion Control Indications (Green)
76
Table 3-1 Battery Voltage LED Indicators
76
Blinking Green
77
Solid Green
77
Blinking Red
78
Equalization Mode Indication (Red/Green)
78
Load Control Indications (Red)
78
Solid Red
78
Error Mode Indication (Orange)
79
Over-Current Condition
79
Over-Temperature Condition
79
Low-Voltage Disconnect Condition
80
Reconnecting to Loads
80
Reset Switch
81
Figure 3-3 Reset Switch
81
Troubleshooting
83
PV Charge Control Troubleshooting
84
Table 4-1 PV Charge Control Problems
84
Diversion Control Troubleshooting
86
Table 4-2 Diversion Control Problems
86
Load Control Troubleshooting
88
Table 4-3 Load Control Problems
88
Specifications
89
Electrical Specifications
90
Table A-1 Electrical Specifications
90
Features and Options Specifications
91
Table A-2 Features and Options Specifications
91
Environmental Specifications
92
Table A-3 Environmental Specifications
92
Battery Types
94
Automotive Batteries
94
Maintenance-Free Batteries
94
Deep-Cycle Batteries
94
Sealed Batteries
95
Nicad and Nife Batteries
96
Battery Sizing
96
Equalization Charging
97
Equalization Setpoints (Non-Sealed Batteries Only)
99
Table B-1 Typical Bulk and Float Setpoints for Batteries
99
Diversion Loads
101
Diversion Load Types
102
Table C-1 Power Dissipation
102
Warranty and Product Information
105
Warranty
105
Disclaimer
106
Return Material Authorization Policy
107
Return Procedure
108
Out of Warranty Service
108
Information about Your System
109
Index
111
5
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the Xantrex C35 and is the answer not in the manual?
Ask a question
Xantrex C35 Specifications
General
Brand
Xantrex
Model
C35
Category
Controller
Language
English
Related product manuals
Xantrex Trace C35
56 pages
Xantrex Trace C60
56 pages
Xantrex Trace C Series
56 pages
SOLAR CHARGE CONTROLLER 30
40 pages
Xantrex XW
124 pages
To Next PageTo Next PageTo Previous PageTo Previous Page
Loading...
Need help?
General
