AAON VCCX-454 - Page 5

VCCX-454 Controller Technical Guide 5
TABLE OF FIGURES
FIGURES
Figure 1: VCCX-454 Controller Components ...................................................................................................................... 12
Figure 2: VCCX-454 Controller Dimensions ....................................................................................................................... 13
Figure 3: A2L Mitigation Controller Components................................................................................................................ 14
Figure 4: BD-3PI Third Party Interface Dimensions ...........................................................................................................15
Figure 5: VCC-X EM1 Expansion Module Dimensions ..................................................................................................... 16
Figure 6: 12 Relay E-BUS Module Dimensions .................................................................................................................. 17
Figure 7: VCCX-454 Controller Input Wiring ....................................................................................................................... 18
Figure 8: VCCX-454 Controller Output Wiring .................................................................................................................... 19
Figure 9: A2L Mitigation Controller Wiring Diagram - Air Flow ......................................................................................... 20
Figure 10: A2L Mitigation Controller Wiring Diagram - Cabinet ......................................................................................... 20
Figure 11: BD-3PI Third Party Interface Module Wiring ...................................................................................................... 21
Figure 12: OMNIMATE Connector Instructions .....................................................................................................................22
Figure 13: Entering Water Temperature Sensor, Return Air Plenum Pressure
and Return/Exhaust Proof of Flow ....................................................................................................................... 23
Figure 14: Direct Fire Wiring .................................................................................................................................................... 23
Figure 15: EM1 Exhaust Duct Static Pressure and Economizer Actuator Feedback Wiring ......................................... 24
Figure 16: EM1 Expansion Module Output Wiring ............................................................................................................... 25
Figure 17: 12 Relay E-BUS Expansion Module Wiring ....................................................................................................... 26
Figure 18: EBTRON GTC116 or HTN104 Series, GreenTrol GA-200-N Series,
and Paragon MicroTransEQ Series Airow Measurement Digital Transmitter Wiring ................................. 27
Figure 19: Analog Input Pin Diagram ..................................................................................................................................... 31
Figure 20: Prism 2 ALARM Button .......................................................................................................................................... 55
Figure 21: Prism 2 ALARM Menu ............................................................................................................................................ 55
Figure 22: Prism 2 Direct Fire Alarms Screen ....................................................................................................................... 57
Figure 23: Prism 2 Compressor Alarms Screen ................................................................................................................... 58
Figure 24: Prism 2 EVAP Module Alarms Screen ................................................................................................................. 58
Figure 25: VCCX-454 Controller LED Locations .................................................................................................................. 67
Figure 26: EM1 Expansion Module LED Locations .............................................................................................................. 67
Figure 27: A2L Controller LED Locations .............................................................................................................................. 68
Figure 28: BD-3PI LED Locations ........................................................................................................................................... 68
Figure 29: Typical Networked Single Loop System Layout ................................................................................................ 72
Figure 30: Typical Networked Multiple Loop System Layout .............................................................................................. 73
Figure 31: LCD Display and Navigation Keys ....................................................................................................................... 74
Figure 32: VCCX-454 BACnet Connection to MS/TP or IP Network................................................................................ 81