Ammann ARR 1575 Yanmar - Forbidden Activities - Safety and Guarantee

22 ARR1575
2.1. Major Safety Precautions
2.1.4. Forbidden activities – safety andguaran-
tee
It is prohibited:
• To use the machine in a case of an obvious defect.
• To use the machine when the level of any operating uid
is low.
• To repair the engine without authorization – except com-
mon changes of operating uids and lters, only an au-
thorized service organization is allowed to intervene in the
engine, including the peripheral components of the engine
(for example, the alternator, the starter, the thermostat, the
electrical installation of the engine.
• To operate the machine in explosive atmosphere and under-
ground.
• To use the machine under the inuence of alcohol or drugs.
• To use the machine if its operation might pose risk to its
technical condition, to safety (life, health) of persons, to fa-
cilities or objects or to road trac and its uency.
• To put the machine into operation and use it when other
persons are within its hazardous reach – the exception is
training of a driver by an instructor.
• To put the machine into operation and use the machine
when any of its safety devices has been removed or is dam-
aged.
• To drive the machine and use it for compacting at such
slopes where the machine stability would be breached
(overturning). The stated machine static stability is reduced
by dynamic eects of driving.
• To drive the machine and use it for compacting at such
slope angles where there is hazard of soil breaking o under
the machine or a risk of a loss of adhesion and uncontrolled
skidding.
• To control the machine in any other way than stated in op-
eration manual.
• To drive and compact with vibration in such a distance from
the slope edge or trenches where there is a hazard of land-
slide or shoulder breaking o with the machine.
• To drive and compact with vibration in such a distance from
walls, cuts and slopes where their collapse could occur and
the machine could be buried under.
• Driving with vibration on hard (frozen, concrete, overcom-
pacted) surface or on bedrock. There is a danger of damage
to the machine.
• To compact with vibration in such a distance from buildings,
facilities or equipment, within which risk of their damage
due to vibration could occur due to the transmission of vi-
brations.
• To move and transport persons on the machine.
• To operate the machine with the bonnet lifted o.
• To operate the machine if there are other machines or
means of transport within its hazardous reach, except those
that operate in mutual cooperation with the machine.
• To operate the machine at a place that is not seen from the
driver’s stand and where hazard to people or property could
occur unless work safety is ensured by another way, e.g. with
mediate signalling by a duly instructed person.
• To operate the machine in a protected zone of electric lines
or substations.
• Do not cross electric cables if they are not properly protect-
ed against mechanical damage.
• To operate the machine at reduced visibility or at night, un-
less the machine’s working area and the workplace are suf-
ciently illuminated.
• To sit on the railing or on the outside parts of the machine
when driving.
• To leave the machine unattended – to move away from the
machine without having prevented its misuse.
• To disable safety, protective or locking systems or alter their
parameters.
• To use the machine with leaking oil, fuel, cooling liquid or
other llings.
• To start the engine in a dierent way than specied in the
operation manual.
• To lay materials or other objects on the machine.
• To remove dirt while the machine is running.
• To perform maintenance, cleaning or repairs when the ma-
chine is not secured against spontaneous move or acciden-
tal start and when contact of a person with moving parts of
the machine is not excluded.
• To touch moving parts of the machine with the human body
or objects and tools held in hands.
• To smoke or handle a naked ame when checking or pump-
ing fuels, exchanging or relling oils, lubricating the ma-
chine and inspecting or relling the accumulator.
• To carry rags saturated from inammable materials and in-
ammable liquids in unbound/loose vessels on the machine
(in the engine space).
• To run the engine inside a closed area. Exhaust fumes are
dangerous to life.
• To perform any adjustments on the machine without the
prior consent of the manufacturer.
• To move electrical conductors.
• To use other than original spare parts.
• To intervene in the electrical and electronic units in any
manner.
• To ll the hydraulic circuit during the guarantee period in a
dierent way than using the hydraulic unit.
Breaching these provisions can inuence the evaluation
of a possible complaint and eect of the machine guar-
antee period.