Argo Aurora 800 - 20;20 Service Chart

45
SECTION 7
MAINTENANCE INFORMATION
20/20 SERVICE CHART
20-POINT INSPECTION AFTER 20 HOURS OF OPERATION
√ Changeengineoilandlter
√ Inspectairlter
√ Changetransmissionoil
√ Inspectandadjustchaintensioners
√ Inspectsteeringandstoppingbrakeoperation
√ Checktightnessofallbearingandsprocketsetscrews
√ Greaseinner,outer&outputshaftbearings
√ Lubricatedrivechains
√ Inspectandcleanairintake
√ Inspectelectricalsystem
√ Inspectlowerbodyandskidplate
√ Adjustandsettirepressures
√ Cleanbatteryposts/checkchargingsystemoperation
√ Checkengineidlespeed&topnoloadRPM,
adjust as required
√ Adjustparkingbrakecable
√ Inspectfuelsystemandlter
√ InspectCVT’s&belt.Adjustsecondaryclutchasre-
quired
√ Re-torqueaxlebearingandextensionbolts
√ Adjuststeeringplungerpinsifrequired
√ OperationalcheckofallArgoAccessories
100/12 SERVICE CHART
100 HOURS OR ONCE-A-YEAR SERVICE
√ Change engine oil and lter
√ Inspect air lter
√ Change transmission oil
√ Inspect and adjust chain tensioners
√ Inspect steering and stopping brake operation
√ Check tightness of all bearing and sprocket set
screws
√ Grease inner, outer & output sha bearings
√ Lubricate drive chains
√ Inspect and clean air intake
√ Inspect electrical system
√ Inspect lower body and skid plate
√ Adjust and set tire pressures
√ Clean battery posts/check charging system operation
√ Check engine idle speed & top no load RPM, adjust
as required
√ Adjust parking brake cable
√ Inspect fuel system and lter
√ InspectCVT’s&belt.Adjustsecondaryclutchas
required
√ Re-torqueaxlebearingandextensionbolts
√ Adjuststeeringplungerpinsifrequired
√ OperationalcheckofallArgoAccessories
√ Changeprimaryairlter
√ Inspectsecondaryairlter
√ Degrease/cleandrivechainsandre-lubricate
√ Inspectallbearingsforwear
√ Inspectlowerbody/skidplatefordamage
√ Inspectdrainplugseal
√ De-greaseandpowerwashvehicle
√ Replacefuellter
√ Replacesparkplugs
√ Inspectchainsliderblocks
√ Cleanandinspectsparkarrester
√ Inspectsprocketsforwear
√ Checkfanbeltforwear