Banner A-GAGE MINI-ARRAY MAC Series - Controller Specifications

P/N 43298 rev. E 11
Banner Engineering Corp. •Minneapolis,MNU.S.A.
www.bannerengineering.com•Tel:763.544.3164
MINI-ARRAY
®
InstructionManual
2.3 Controller Specifications
Specifications
Power Requirements
16to30Vdc@1.25ampsmax.(seecurrentrequirementsforsensors);
Controlleralone(withoutsensorsconnected)requires0.1amp.
Inputs
MINI-ARRAYsensorinput(5connections);emitterandreceiverwireinparalleltofive
terminals.
GATEinput:Optically-isolated,requires10to30Vdc(7.5Kinputimpedance)forgatesignal.
System Response Time
Outputsarenotactivefor5secondsaftersystempowerup.Maximumresponsetimeforthe
discreteoutputsistwoscancycles.Ascancycleincludesasensorscanplusanyserialdata
transmission.
Serialtransmission(ifactivated)followseverysensorscan.
Discrete Outputs
MAC-1:
Output1(OUT1):Reedrelaycontactrated125Vac/dcmax.,10VAmax.resistive
load(non-inductive).
Output2(ALARM):OpencollectorNPNtransistorrated30Vdcmax.,150mAmax,
short-circuitprotected(maybeconfiguredasaseconddataanalysisoutput,system
alarmoutput,orscantriggeroutputforaparallelarray).
OFF-STATELeakageCurrent:<10µA@30Vdc
ON-STATESaturationVoltage:<1Volt@10mA,<1.5Volt@150mA
MACN-1: (2)OpencollectorNPNtransistoroutputs.
MACP-1:(2)OpencollectorPNPtransistoroutputs.
Transistorrated30Vdcmax.,150mAmax,shortcircuitprotected(maybe
configuredasaseconddataanalysisoutput,systemalarmoutput,orscantrigger
outputforaparallelarray).
OFF-STATELeakageCurrent<10µA@30Vdc
ON-STATESaturationVoltage<1Volt@10mA,<1.5Volt@150mA
MACV-1/MACI-1:Alarm:OpencollectorNPNtransistorrated30Vdcmax.150mAmax,short
circuitprotected.
(maybeconfiguredasadataanalysisoutput,systemalarmoutput,orscan
triggeroutputforaparallelarray)
OFF-STATELeakageCurrent:<10µA@30Vdc
ON-STATESaturationVoltage:<1Volt@10mA,<1.5Volt@150mA
MAC16P-1:SixteenopencollectorPNPtransistoroutputs.
MAC16N-1: SixteenopencollectorNPNtransistoroutputs.
30Vdcmax,150mAmax.,shortcircuitprotected.
OFF-STATEleakagecurrent:<10µA
ON-STATESaturationVoltage:<1Volt@10mA;<1.9V@150mA
Analog Outputs
MACV-1: (2) 0-10VoltssourcingadjustableNullandSpan(20mAcurrentlimit).
MACI-1: (2)4-20mAcurrentsinkingadjustableNullandSpan(16to30Vinput).
Resolution:
SpanminusNull,dividedbythenumberofsensorchannels
Linearity:
0.1%ofFullScale
Temp. Var.:
0.01%ofFullScale/°C
Serial Data Outputs
All Models: RS-232,ASCIIorbinarydataformat.
Baudrate:9600,19.2K,or38.4K8databits,1startbit,1stopbit,evenparity.
Cleardatamaybesuppressed;headerstringmaybesuppressedinbinary
format.
MAC-1, MACN-1,
and MACP-1:
Upto15ControllersmaybegivenuniqueaddressforRS-485partyline.
Controller Programming
ViaRS-232toPC-compatiblecomputerrunningWindows
®
.XP, Vista, or 7
operatingsystemandusingBanner-suppliedsoftware(seeusermanual).