T-361 4–4
4.1.6 Miscellaneous Engine Troubleshooting
4.2 BATTERY CHARGER (SOLID STATE)
Table 4–6 Miscellaneous Engine Troubleshooting
Condition Possible Cause Remedy/Reference Section
Loss of power Restriction in air cleaner Section 5.5.11
Air in fuel system Section 5.5.11
Air vent restricted Clean
Restricted fuel lines Engine Manual
Fuel injection pump is bad Engine Manual
Injector(s) bad or incorrect type used Engine Manual
Incorrect fuel injection pump timing Engine Manual
Incorrect valve timing Engine Manual
Poor compression Engine Manual
Vibration Engine shockmounts are bad Replace
Poor compression Engine Manual
Overheating Restriction in air cleaner Section 5.5.11
Exhaust pipe restriction Remove
Restriction in water jacket Engine Manual
Restriction in radiator Section 5.5.5
Coolant level too low Section 2.11.
Loose water pump/alternator poly V-belt Section 5.5.10
Thermostat is bad Engine Manual
Water pump is bad Engine Manual
Excessive crankcase pressure Plugged crankcase breather line Section 5.5.12
Table 4–7 Battery Charger (Solid State)
Condition Possible Cause Remedy/Reference Section
CB4 trips when charger is
turned on
Short in 12-volt wiring causing overload of
charger
Locate and remove short or
replace charger
Circuit breaker trips
repeatedly, even when not
connected
Internal short Replace charger
Charger does not taper back
after charging for a few
minutes
Bad cell in battery Test battery for defect according to
battery manufacturer’s instructions
Charger is bad Replace
To Next Page
Loading...
