Operation Monitoring
53
C3M2-OM-EN-02
Routine Maintenance Pop Up Icon
The routine maintenance icon pops up on the screen along with the
message “Service Required!” when routine maintenance is due.
Initially it will be displayed after 100 operating hours.
After the first 100-hour service the icon must be set to pop up every
250 operating hours in accordance with the maintenance schedule.
Contact your local Combilift partner for further information.
Low Engine Oil Pressure Pop Up Icon
The low engine oil pressure icon pops up on the screen along with
the message “Low Engine Oil Pressure!” when the ECU has
detected that the engine oil pressure is below the expected range.
Switch off the engine immediately as it can be severely damaged if
oil pressure is lost.
Investigate the cause of the low oil pressure warning.
The low pressure may be due to low oil level (see 5.3 ‘Checking
Engine Oil Level’ on page 66).
High Engine Temperature Pop Up Icon
The high engine temperature icon pops up on the screen along with
the message “High Engine Temperature!” when the ECU has
detected that the engine coolant is overheating.
Allow the engine to idle for at least 5 minutes to let it cool down
gradually, then stop the engine.
Investigate the cause of the overheating before resuming operation.
Check the coolant level, look for coolant leaks.
Check for obstructions around the cooling air inlet or outlet.
Check for dirt or dust between the radiator fins.
Check the fan belt tension.
Check the radiator water pipes for blockages.
If operation is continued and the coolant temperature rises further -
at a critical temperature above 100°C (212°F) - engine performance
is automatically reduced to protect the engine against the effects of
overheating.
Drain Water Separator Pop Up Icon *
The drain water separator icon pops up on the screen along with
the message “Drain Water Separator!” when water is detected in
the water trap on the bottom of the fuel filter element.
Stop the engine immediately and drain all water from the water trap
(see 6.9Diesel Fuel System on page 105).
* Diesel engine powered trucks only.
To Next Page
Loading...
