Name: Dell Embedded Box PC5000
Brand: Dell
Rating: 5 (1 reviews)

To Next Page

To Previous Page

2 Push the WLAN-antenna connectors through the chassis.

1 chassis 2 WLAN-antenna connectors

two

3 WLAN-antenna connectors

one

3 Disconnect the antenna cables from the WLAN card.

4 Remove the WLAN-antenna cables from the WLAN-cable routing guides on the

chassis.

Default Chapter3
- Table of Contents3
Before Working Inside Your Embedded Box PC11
- Before You Begin11
- Safety Instructions11
- Recommended Tools12
- Screw List13
After Working Inside Your Embedded Box PC15
Technical Overview16
- System-Board Components17
Removing the Back Cover19
- Procedure20
Replacing the Back Cover23
- Procedure23
Removing the Hard-Drive Cage24
- Prerequisites24
- Procedure24
Replacing the Hard-Drive Cage26
- Procedure26
- Post-Requisites26
Removing the Drives from the Hard-Drive Cage27
- Prerequisites27
- Procedure27
  - Procedure to Remove Bottom Drive28
Replacing the Drives in to the Hard-Drive Cage30
- Procedure30
  - Procedure to Replace Bottom Drive30
- Post-Requisites30
Removing the Solid-State Drive from Bracket31
- Prerequisites31
- Procedure31
Replacing the Solid-State Drive in to Bracket33
- Procedure33
- Post-Requisites33
Removing the Interposer Board34
- Prerequisites34
- Procedure34
Replacing the Interposer Board36
- Procedure36
- Post-Requisites36
Installing a Pci/Pcie Card37
- Prerequisites37
- Procedure38
- Post-Requisites42
Removing the Pci/Pcie Card43
- Prerequisites43
- Procedure44
Replacing the Pcie Card47
- Procedure47
- Post-Requisites49
Removing the Memory Module50
- Prerequisites50
- Procedure50
Replacing the Memory Module52
- Procedure52
- Post-Requisites54
Removing the WLAN-Antenna Connectors55
- Prerequisites55
- Procedure55
Replacing the WLAN-Antenna Connectors58
- Procedure58
- Post-Requisites58
Removing the WLAN Card59
- Prerequisites59
- Procedure59
Replacing the WLAN Card61
- Procedure61
- Post-Requisites63
Removing the WWAN-Antenna Connectors64
- Prerequisites64
- Procedure64
Replacing the WWAN-Antenna Connectors67
- Procedure67
- Post-Requisites67
Removing the WWAN Card68
- Prerequisites68
- Procedure68
Replacing the WWAN Card70
- Procedure70
- Post-Requisites72
Removing the SIM Card73
- Prerequisites73
- Procedure73
Replacing the SIM Card75
- Procedure75
- Post-Requisites76
Removing the Canbus Cable77
- Prerequisites77
- Procedure77
Replacing the Canbus Cable79
- Procedure79
- Post-Requisites79
Removing the Canbus Card80
- Prerequisites80
- Procedure80
Replacing the Canbus Card82
- Procedure82
- Post-Requisites83
Removing the Coin-Cell Battery84
- Prerequisites84
- Procedure84
Replacing the Coin-Cell Battery86
- Procedure86
- Post-Requisites86
Removing the Intrusion Switch87
- Prerequisites87
- Procedure87
Replacing the Intrusion Switch89
- Procedure89
- Post-Requisites89
Removing the Serial Ports90
- Prerequisites90
- Procedure91
Replacing the Serial Ports93
- Procedure93
- Post-Requisites93
Removing the Bottom Cover94
- Prerequisites94
- Procedure94
Replacing the Bottom Cover96
- Procedure96
- Post-Requisites96
Removing the Riser Card97
- Prerequisites97
- Procedure97
Replacing the Riser Card100
- Procedure100
- Post-Requisites100
Removing the Heat Sink101
- Prerequisites101
- Procedure101
Replacing the Heat Sink103
- Procedure103
- Post-Requisites104
Removing the Power Connectors105
- Prerequisites105
- Procedure105
Replacing the Power Connectors108
- Procedure108
- Post-Requisites108
Removing the Top Cover109
- Prerequisites109
- Procedure109
Replacing the Top Cover112
- Procedure112
- Post-Requisites112
Removing the Power Switch113
- Prerequisites113
- Procedure113
Replacing the Power Switch115
- Procedure115
- Post-Requisites115
Removing the CPU Board116
- Prerequisites116
- Procedure116
Replacing the CPU Board118
- Procedure118
- Post-Requisites118
Removing the System Board119
- Prerequisites119
- Procedure120
Replacing the System Board123
- Procedure123
- Post-Requisites123
- Entering the Service Tag in the BIOS Setup Program124
BIOS Setup Program125
- Entering BIOS Setup Program125
- Clearing Forgotten Passwords125
- Clearing CMOS Settings126
Removing the Dell Logo Board128
- Prerequisites128
- Procedure129
Replacing the Dell Logo Board132
- Procedure132
- Post-Requisites132
Technology and Components134
- Power134
- Processor134
- Mechanical134
- Peripherals135
- Wlan/Wwan135
- Zigbee135
- Canbus136

Brand	Dell
Model	Embedded Box PC5000
Category	Computer Hardware
Language	English

Dell Embedded Box PC5000 Service Manual

Table of Contents

Questions and Answers:

Dell Embedded Box PC5000 Specifications

Related product manuals