Doosan D35C-5 User Manual

Operation Section
-99-
Problem Probable Cause Corrective Action
Difficult to Start
(Gas)
Fuel tank almost empty Fuel Pump Cavitations
z The tank should be at least ¼ full to
properly prime the fuel pump
z Fuel select switch is not on GAS
Clogged fuel filte
r
Repair/replace as required
z See Maintenance section, Primary and
Secondar
y
Fuel Filter replacement
Electric Fuel Pump malfunction
(GAS)
Check electrical connection
z Check Relay and fuse Turn key ON
and verify pump is operating
z Se
e
En
g
ine Service Manual
Pressure regulator malfunction Test pressure regulator operation
z Se
e
En
g
ine Service Manual
Fuel Injector malfunction Test Injector operation
z Se
e
Engine Service Manual
Air filter clogged Check air filter
z Clean/replace as required
Incorrect air/fuel or ignition control See Advanced Diagnostics
En
g
ine Mechanical See En
g
ine Service Manual
Will Not Run
Continuously
(Gas)
Isolate the gasoline system by
running the lift truck on LPG
Verify LPG cylinder is full and valve is open.
If the problem does not exist in LPG mode
proceed with the corrective action steps
below.
If the problem also exists in LPG mode then
the root cause is most likely to be
something other than the fuel system
z See Advanced Diagnostics
Fuel tank almost empty Fuel Pump Cavitations
z The tank should be at least ¼ full to
properly prime the fuel pump
Clogged fuel filte
r
Repair/replace as required
z See Maintenance section, Primary and
Secondary Fuel Filter replacement

Doosan D35C-5 Specifications

General

Brand	Doosan
Model	D35C-5
Category	Lifting Systems
Language	English