G643 (E) Service Manual Chapter 3. Engine Mechanical System 44
LOWER ENGINE PARTS
ITEM # DESCRIPTION ITEM # DESCRIPTION
1 RING KIT, PISTON (STD) 48 FITTING, O IL FILTER
KIT, PISTON (0.50 MM O.S.) 49 FILTER, O IL
2 PISTON KIT, ENGINE (STD) 50 GEAR, FLYWHEEL RING
PISTON KIT, ENGINE (0.50 MM O.S.) 58 BALANCER, CRANKSHAFT
3 ROD, CONN (INCL. BOLTS, CAP, NUT& ROD) 60 BOLT, ENGINE FRONT COVER
4 BOLT, CONN ROD 61 COVER, ENG FRT
5 BEARING KIT, CONN ROD (STD) (INCLS BOLTS, COVER, GROMMETS & SEAL)
7 NUT, CONN ROD (GASKET MOLDED TO COVER)
9 PLUG, ENGINE BLK OIL GAL (RR)(RH) 62 KEY, CRANKSHAFT BALANCER
PLUG, ENGINE BLK OIL GAL (RR)(LH) 63 BEARING KIT, CRANKSHAFT (#1, 2, & 3)
10 PLUG, CM/SHF RR BRG HOLE 64 BEARING KIT, CRANKSHAFT (RR #4)
11 PIN, CR/SHF RR OIL SEAL HSG 65 BOLT, CRANKSHAFT BEARING CAP
12 PIN, CYL. HEAD LOC. 67 GASKET, CRANKSHAFT RR OIL SEAL HSG
13 PIN, TRANS. LOC. 68 STUD, CRANKSHAFT RR OIL SEAL RETAINER
14 PLUG, ENG BLK CORE HOLE 69 BOLT, CRANKSHAFT RR OIL SEAL HOUSING
15 VALVE, OIL FILTER BYPASS 70 BOLT, CRANKSHAFT RR OIL SEAL HOUSING
16 PIN, CM/SHF SPKT LOC. 71 HOUSING, CR/SHF RR OIL SEAL
17 PLUG, ENGINE BLK OIL GAL (FRT)(RH) 75 GASKET, OIL PAN
PLUG, ENGINE BLK OIL GAL (FRT)(LH) 76 AN, OIL (INCL BAFFLE, BOLTS, GSKT, INSER PAN,
18 CAMSHAFT, ENGINE (INCL. #16) PLUG, & SEALER)
19 CHAIN, CM/SHF TMG (IS A ROLLER CHAIN) 77 SEAL, OIL PAN DRAIN PLUG (O-RING)
20 SPROCKET, CM/SHF (SEE ITEM 2A @ END) 78 PLUG, OIL PAN DRAIN (W/MAGNET & SEAL)
21 SPROCKET, CR/SHF (SEE ITEM 2A @ END) 79 BOLT, OIL PAN (HFH 5/16 - 18 X 7/8)
22 BOLT, CM/SHF SPROCKET 80 NUT, OIL PAN (5/16 - 18 X 20)
23 BOLT, CM/SHF SPROCKET RETAINER 82 PLUG, ENG BLK OIL GAL (CUP 15/32 X 5/16)
24 RETAINER, CM/SHF 83 SEAL, CRANKSHAFT SEAL (61.5MM)
25 BEARING, CM/SHF (#1 POSITION) 84 NUT, CR/SHF RR OIL SEAL RET
26 BEARING, CM/SHF (#2 POSITION) 87 PLUG, KNOCK SENSOR HOLE
27 BEARING, CM/SHF (#3 POSITION) 88 BOLT, BALANCER SHAFT GR
28 BEARING, CM/SHF (#4 POSITION) 90 RETAINER, BALANCER SHAFT
31 GASKET, W /PMP (PART O F 35) 91 BALANCER (INCL'S ITEM 121)(INTERNAL)
32 BOLT, WATER PUMP 92 PLUG, BALANCER SHAFT RR BRG HOLE
35 PUMP, W/P (INCLS GASKET & PLUG) 93 BEARING KIT, BALANCER SHAFT
36 SHAFT, O IL PUMP DRIVE 94 BOLT, BALANCER SHAFT RETAINER
37 PIN, O IL PUMP DRIVE 105 GASKET, WATER PUMP COVER
38 RETAINER, O IL PUMP DRIVE SHAFT 106 WASHER, INT-EXT TOOTH
39 PUMP, O IL 107 BOLT, WATER PUMP COVER
40 BOLT, O IL PUMP 108 FLYWHEEL, ENGINE
41 SCREEN, O IL PUMP 109 PLUG, ENGINE BLOCK COOL DRAIN HOLE
42 PLUG, O /P RLF VLV BORE (PT O F 39 & 47) 113 GROMMET, ENGINE FRONT COVER
43 ALVE, O IL PRESSURE RELIEF (PT OF 39 &47 1A GEAR KIT, BAL SHF (INCL DRIVE & DRIVEN GEAR)
44 SPRING, O IL PRESSURE RELIEF VALVE 2A CHAIN KIT, TIMING (INCLS CHAIN, CR/SHF
45 BOLT, O IL PUMP COVER (PT OF 39) SPROCKET & CM/SHF PROCKET)
46 PIN, O /P RLF VLV SPR ST (PT O F 39 & 47) N.S.S. NOT SOLD SEPARATELY
47 COVER, O IL PUMP (PART O F 39)
To Next Page
Loading...
