DriSteem Vapor-logic 4 User Manual

1BHFt%3*45&&.7BQPSMPHJD*OTUBMMBUJPOBOE0QFSBUJPO.BOVBM
5SPVCMFTIPPUJOHHVJEF
Table 85-1:
Troubleshooting guide (continued)
Filling issues
Issue
Possible causes Actions
Alarm:
Excessive fill time
Alarm:
Excessive refill time
Tank is not full.
t 'JMMBOEESBJOWBMWFXJSJOHSFWFSTFE t$PSSFDUXJSJOH
t -PXXBUFSTVQQMZQSFTTVSF t7FSJGZXBUFSQSFTTVSFJTQTJL1BNJOJNVN
t *OMJOFTUSBJOFSQMVHHFE t $MFBOBTOFFEFE
t)VNJEJGJFSDPWFSJOUFSMPDLTXJUDIJNQSPQFSMZ
wired
t $PSSFDUXJSJOH
t'JMMWBMWFOPUPQFO t*G7"$JTQSFTFOUBDSPTTGJMMWBMWFDPJMSFQMBDFWBMWF
t'JMMWBMWFOPUXJSFEQSPQFSMZUPDPOUSPMCPBSE t 7FSJGZQSPQFSGJMMWBMWFXJSJOHBUUFSNJOBM1GJMMESBJO
t5FTUPQFSBUJPOCZHPJOHUPUIF5FTUTFDUJPOVOEFSUIF%JBHOPTUJDT
menu.
t*OMFUXBUFSOFFEMFWBMWFDMPTFEPSQMVHHFE t $IFDLJGOFFEMFWBMWFJTPQFOBOEGSFFPGTFEJNFOU
t 'JMMWBMWFXJUIJODPSSFDUPQFSBUJOHWPMUBHF t7FSJGZWBMWFDPJMJT7"$
t1MVHHFEGJMMWBMWF t 3FNPWFGJMMWBMWFBOEDIFDLGPSGPSFJHONBUFSJBMQMVHHJOHUIF
valve.
t 'JMMWBMWFJOTUBMMFECBDLXBSE t $IFDLBSSPXEJSFDUJPOPOWBMWFPS”In” should be visible on fill
valve body.
t &YDFTTJWFXBUFSIBNNFSDBOCFOEBOFFEMF
valve and make it difficult to open
t3FQMBDFWBMWFJGOFFEFE
t*OTUBMMBXBUFSTVQQMZMJOFTIPDLBSSFTUFS
t0SJGJDFBGUFSGJMMWBMWFNBZCFQMVHHFE t4FSWJDFWBMWFTUSBJOFSBOEPSJGJDFBTTFNCMZ
t%SBJOWBMWFMFBLJOHXBUFS t7FSJGZESBJOJTJOUIF"VUPQPTJUJPOBOEJTDMPTFE
t .JTTJOHQSPCFSPE t 3FQMBDFNJTTJOHQSPCFSPEJGQPTTJCMFPUIFSXJTFSFQMBDFQSPCF
rod assembly.
Tank is full.
t 1SPCFNBMGVODUJPOJOH t$MFBOPSSFQMBDFQSPCF
Low water conductivity:
t 5BQTPGUFOFEXBUFS(54IVNJEJGJFSTBOEFMFDUSJD
humidifiers with heating elements require fill
XBUFSDPOEVDUJWJUZUPCF4DNNJOJNVN
t 95IVNJEJGJFSSFDPNNFOEFEGJMMXBUFS
conductivity is 125 to 1250 μS/cm.
t"EEBEEUBCTPEJVNCJDBSCPOBUFJF"MLB4FMU[FSUP
increase water conductivity. Consult DRI-STEEM for further
advice.
t/PUBOLHSPVOE t*OTUBMMUBOLHSPVOE
t 'JMMWBMWFTUVDLPQFO t $IFDLWBMWFGPSGPSFJHONBUUFS
t 'JMMWBMWFJOTUBMMFECBDLXBSE t $IFDLBSSPXEJSFDUJPOPOWBMWFPS”In” should be visible on fill
valve body.
t &YDFTTJWFDPOEFOTBUFJTESBJOJOHJOUPUIFUBOL t $POTVMU%3*45&&.UPJODSFBTFUIFBNPVOUPGXBUFSUIBUDBOCF
converted to steam before receiving a fault.
Fill valve cycles on and off
frequently (several times per
minute)
For XT humidifiers, see
Check cylinder / high water on Page 47 of Table 45-1.
t .BMGVODUJPOJOHMFWFMDPOUSPMTZTUFN
t *GOFFEFEDMFBOQSPCFT
t $IFDLXBUFSDPOEVDUJWJUZ.JOJNVNDPOEVDUJWJUZGPSQSPQFS
PQFSBUJPOPGMFWFMDPOUSPMTZTUFNJT4DN
t 7FSJGZUIBUQSPCFXJSJOHJTDPSSFDU
t %SBJOWBMWFOPUGVMMZDMPTFE
t *GBOPCTUSVDUJPOEPFTOPUBMMPXESBJOWBMWFUPGVMMZDMPTFDMFBO
valve.
t *GUIFSFJTBCSPLFOPSXFBLSFUVSOTQSJOHPOESBJOWBMWFSFQMBDF
the valve.
t $IFDLJG7"$JTQSFTFOUBUWBMWF*GTPDIFDLXJSJOHPG
Vapor-logic4
control board terminal P17 (drain).
t1PPSUBOLHSPVOE t7FSJGZHPPENBDIJOFHSPVOE
Continued
Operation

DriSteem Vapor-logic 4 Specifications

General

Brand	DriSteem
Model	Vapor-logic 4
Category	Controller
Language	English