Parts
332291P 35
▲Replacement safety labels, tags, and cards are
available at no cost.
❖ Also order Ref 27, Part No. 123025 and Ref 60, Part
No. 16D984
† Also order Ref. 57, Part No. 117156 when ordering
this part.
Pressure Relief Valves
Important Information regarding Pressure Relief
Valve 16C807.
◆ Pressure Relief Valve 16C807 can only be used on
the G3, G1, or G-Mini Pumps. It is not intended for use
with any other products.
The pressure relief valve uses a
pressure adjustment screw (a) to
set the pressure release point. It
is not intended as a way to
relieve pressure during normal
operation, but as a protective
measure in the event there is an
unintended pressure increase in
the system. Do not use this pres-
sure relief valve a means of
relieving pressure in day-to-day,
normal cycle operation.
The pressure adjustment screw
may require periodic adjust-
ments. Whenever the valve is set/adjusted (after the set
point is found) it is important to ensure that the valve is
not bottomed out and there is at least 1/2 turn of
adjustment remaining. This is determined by turning the
screw (a) 1/2 turn and then back turning it out again.
NOTE: Turning adjustment screw (a) clockwise
increases pressure.
NOTE: Each pressure relief valve requires banjo kit p/n
571058. (Except 16C807 because the banjo is already
included in Kit 571028.)
73 SCREW, machine 2
74 SPRING, plate, valve, reset 1
75▲ 15H108 LABEL, safety, pinch 1
81 VALVE, AFSO 1
82 BOLT, mounting 1
83 PACKING, o-ring 1
84 PACKING, o-ring 1
85 SEAL, upper, reservoir 1
87 SEAL, lower, reservoir 1
88 SPACER, seal, base 1
89 PLATE, valve 1
200 127783 CABLE,15 ft (4.5 m), SOOW w/7pos, 3
pin, 90 deg (See Wiring Diagram, page
15)
1
16U790 CABLE, DIN, to flying leads (See Wiring
Diagram, page 14)
1
201 124300 CABLE, M12, 16.5 ft (5m), 4 wire,
straight male to flying leads (See Wire
and Installation Diagrams, page 14)
1
124333 CABLE, M12, 16.5 ft (5m), 4 wire,
straight male to female (See Wiring Dia-
gram, page 17)
1
202 124301 CONNECTOR, straight, M12 female, 4
Pin
1
124594 CONNECTOR, straight, M12 female
(see Wire and Installation Diagrams,
page 14)
1
124595 CONNECTOR, straight, M12 male, (see
Wire and Installation Diagrams, page
14)
1
Ref Part Description Qty
Part Description Qty
16C807◆
VALVE, pressure relief, 500-3500 psi (3.44
MPa, 34.4 bar - 24.1 MPa, 241 bar), Set
pressure 3000 psi +
10% (20.68 MPa,
206.8 bar +
10%) Included in Kit 571028
1
563156
VALVE, pressure relief, 750 psi (5.17 MPa,
51.71 bar)
1
563157
VALVE, pressure relief, 1000 psi (6.89
MPa, 68.95 bar)
1
563158
VALVE, pressure relief, 1500 psi (10.34
MPa, 103.42 bar)
1
563159
VALVE, pressure relief, 2000 psi (13.78
MPa, 137.89 bar)
1
563160
VALVE, pressure relief, 2500 psi (17.23
MPa, 172.36 bar)
1
563161
VALVE, pressure relief, 3000 psi (20.68
MPa, 206.84 bar)
1
a
ti15644
b
a = adjustment screw
b = locking nut
To Next Page
Loading...
