Jungheinrich HC 110 - Prior to Decommissioning; During Decommissioning

5.1 Prior to decommissioning
Procedure
• Thoroughly clean the truck.
WARNING!
Faulty brakes can cause accidents
Test the brakes immediately as soon as the truck has been commissioned.
u
Report any defects immediately to your supervisor.
u
Tag out and decommission a faulty lift truck.
u
Only return the truck to service when you have identified and rectified the fault.
Test the brakes.
• Check the hydraulic oil level and replenish if necessary, see page 54.
• Apply a thin layer of oil or grease to any non-painted mechanical components.
• Lubricate the truck according to the lubrication schedule, see page 54.
• Charge the battery, see page 29.
• Disconnect the battery, clean it and grease the terminals.
Z
In addition, follow the battery manufacturer’s instructions.
• Spay all exposed electrical contacts with a suitable contact spray.
5.2 During decommissioning
NOTICE
Full discharge can damage the battery
Self-discharge can cause the battery to fully discharge. Full discharge shortens the
useful life of the battery.
u
Charge the battery at least every 2 months.
Z
Charge the battery, see page 29.
62
04.16 en-GB