Kinze 851 - Default Chapter; Table of Contents

TM
Grain CartM0276-01
Rev. 4/19 i
Table of Contents
OVERVIEW
To the Owner ....................................1-1
Warranty ........................................1-3
General Information ...............................1-3
Introduction. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-3
Specifications ....................................1-4
General Safety Rules ..............................1-5
Safety Instructions, Signs, and Decals . . . . . . . . . . . . . . . . .1-6
OPERATION
Shipping Tie Downs ...............................2-1
Shipping Location. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-1
Machine Preparation ..............................2-2
Tractor Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-2
Tractor Preparation and Hookup. . . . . . . . . . . . . . . . . . . . . .2-2
Cart Operation ...................................2-5
Auger Fold Enable/Disable . . . . . . . . . . . . . . . . . . . . . . . . . .2-7
Unload Grain Cart ................................2-8
PTO Torque Limiting/Overrunning Clutch Protection ......2-9
Auger Cleanout Door .............................2-10
Vertical Auger Work Light . . . . . . . . . . . . . . . . . . . . . . . . . .2-12
Cameras .......................................2-12
Manual and Electric Roll Tarp .......................2-13
Roll Tarp Remote Control Troubleshooting . . . . . . . . . . . . .2-15
Track System Components. . . . . . . . . . . . . . . . . . . . . . . . .2-16
Track Transport Speeds ...........................2-17
Track System Minimum Turning Radius Limitations . . . . . .2-18
Track System Break-In Procedures ..................2-18
Track System Operational Guidelines. . . . . . . . . . . . . . . . .2-19
Electronic Scale - GT 400. . . . . . . . . . . . . . . . . . . . . . . . . .2-20
Grain Moisture Sensor ............................2-22
Grain Moisture Sensor Testing . . . . . . . . . . . . . . . . . . . . . .2-23
Grain Moisture Sensor Calibration ...................2-24
Electronic Scale Printing Options . . . . . . . . . . . . . . . . . . . .2-25
Electronic Scale - GT 560 AutoLog ..................2-26
Electronic Scale Troubleshooting ....................2-29
Electronic Scale Troubleshooting ....................2-30
Data Downloader Troubleshooting ...................2-31
Track System Troubleshooting ......................2-32
LUBRICATION AND MAINTENANCE
Wheel Bearings ..................................3-1
Gearbox Oil Level . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-2
PTO Shaft Coupling ...............................3-2
Grease Fittings ..................................3-3
Lubrication Points . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-4
Track System Maintenance. . . . . . . . . . . . . . . . . . . . . . . . . .3-6
Check Track Alignment . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-8
Track Alignment Procedure. . . . . . . . . . . . . . . . . . . . . . . . . .3-9
Track System Inspection ...........................3-10
Track Removal ..................................3-11
Track Installation. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-14
Mounting Bolts and Hardware ......................3-15
Torque Values Chart - Plated Hardware ...............3-15
Special Torque Values ............................3-15
Vertical Auger Counter Balance Valves ...............3-17
Wheel Servicing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-17
Tire Servicing ...................................3-18
Driveline Inspection ..............................3-19
Upper Vertical Auger Replacement ..................3-20
Lower Vertical Auger Replacement ..................3-21
Wheel Bearing Replacement .......................3-22
Preparation for Storage ...........................3-23
Hydraulic Control Schematic - Manual . . . . . . . . . . . . . . . .3-26
Wiring Diagram. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-27
Electronic Schematic . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-28
Moisture Sensor Harness Routing ...................3-29
Autolog Sensor Harness Routing . . . . . . . . . . . . . . . . . . . .3-30
Electronic Scale .................................3-31