EasyManuals Logo

KTM RC 200 User Manual

KTM RC 200
211 pages
To Next Page IconTo Next Page
To Next Page IconTo Next Page
To Previous Page IconTo Previous Page
To Previous Page IconTo Previous Page
Page #174 background imageLoading...
Page #174 background image
21 TROUBLESHOOTING 172
Faults Possible cause Action
Engine overheats Defect in radiator fan system Check the radiator fan system.
The engine diagnosis warning
lamp (MIL) lights up red
Fault in fuel injection system Read out the fault memory using the KTM diag-
nostics tool.
Engine dies during the trip Lack of fuel Refuel. ( p. 70)
Fuse 1, 3, 4, or 7 is blown Change the fuses of individual power consumers.
( p. 138)
The ABS warning lamp lights up
(RC 125)
ABS fuse is blown Change the ABS fuses. ( p. 136)
Large difference in wheel speeds of the
front and rear wheels
Stop the vehicle, switch off the ignition, and
start it again.
Malfunction in ABS Read out the ABS fault memory using the KTM
diagnostics tool.
High oil consumption Engine vent hose bent Route the vent hose without bends or change it if
necessary.
Engine oil level too high Check the engine oil level. ( p. 160)
Engine oil too thin (low viscosity) Change the engine oil and oil filter, clean the oil
screen. ( p. 160)
Headlight and parking light are not
functioning
Fuse 6 blown Change the fuses of individual power consumers.
( p. 138)
Turn signal, brake light, and horn are
not functional
Fuse 6 blown Change the fuses of individual power consumers.
( p. 138)
Time is not (correctly) displayed Fuse 7 is blown (RC 125) Change the fuses of individual power consumers.
( p. 138)
Set the clock. ( p. 54)
Battery discharged Ignition was not switched off when
vehicle was parked
Recharge the battery. ( p. 133)

Table of Contents

Questions and Answers:

Question and Answer IconNeed help?

Do you have a question about the KTM RC 200 and is the answer not in the manual?

KTM RC 200 Specifications

General IconGeneral
Displacement199.5 cc
Transmission6-speed
Fuel SystemElectronic Fuel Injection
Rear SuspensionWP APEX Monoshock
Bore x Stroke72 mm x 49 mm
Compression Ratio11.5:1
Max Power25 PS @ 10000 rpm
Max Torque19.2 Nm @ 8000 rpm
Front Brake300 mm disc
Rear Brake230 mm disc
Fuel Tank Capacity13.7 liters
Kerb Weight160 kg
Front SuspensionWP APEX 43 mm Upside Down
ABSDual Channel
Tyre Front110/70-17
Tyre Rear150/60-R17
Ground Clearance157 mm
Engine TypeSingle Cylinder, Liquid Cooled

Related product manuals