Lenovo ThinkSystem SR860 - Default Chapter; Table of Contents

Contents
Safety . . . . . . . . . . . . . . . . . . iii
Safety inspection checklist . . . . . . . . . . . iv
Chapter 1. Introduction . . . . . . . . . 1
Specifications . . . . . . . . . . . . . . . . 1
Firmware updates . . . . . . . . . . . . . . . 5
Configuring the LAN over USB interface
manually. . . . . . . . . . . . . . . . . 8
Installing the LAN over USB Windows device
driver . . . . . . . . . . . . . . . . . . 8
Tech Tips . . . . . . . . . . . . . . . . . . 9
Security advisories . . . . . . . . . . . . . . 9
Power on the server . . . . . . . . . . . . . 10
Power off the server . . . . . . . . . . . . . 10
Chapter 2. Server components . . . . 11
Front view . . . . . . . . . . . . . . . . . 12
Front operator panel . . . . . . . . . . . 14
Front operator panel with LCD display . . . . 15
Rear view . . . . . . . . . . . . . . . . . 19
System-board connectors. . . . . . . . . . . 24
Switches, jumpers, and buttons . . . . . . . . 25
System-board LEDs . . . . . . . . . . . . . 26
PCIe expansion tray . . . . . . . . . . . . . 27
4U PCIe riser assembly . . . . . . . . . . . . 29
Optional processor and memory expansion tray . . 29
PCIe riser cards. . . . . . . . . . . . . . . 32
2.5-inch drive backplanes . . . . . . . . . . . 33
RAID adapters . . . . . . . . . . . . . . . 34
Internal cable routing. . . . . . . . . . . . . 35
Guideline for cable routing for 2.5-inch
drives . . . . . . . . . . . . . . . . . 35
Cable routing for 2.5-inch drives to one
backplane . . . . . . . . . . . . . . . 38
Cable routing for 2.5-inch drives to two
backplanes. . . . . . . . . . . . . . . 41
Parts list. . . . . . . . . . . . . . . . . . 54
Power cords . . . . . . . . . . . . . . 58
Chapter 3. Hardware replacement
procedures . . . . . . . . . . . . . . . 59
Installation Guidelines . . . . . . . . . . . . 59
System reliability guidelines . . . . . . . . 60
Handling static-sensitive devices . . . . . . 61
Replace components in the server . . . . . . . 61
2.5-inch hot-swap drive and drive backplane
replacement . . . . . . . . . . . . . . 61
Chassis air baffle replacement . . . . . . . 65
CMOS battery - CR2032 replacement . . . . 67
Fan and fan cage replacement . . . . . . . 71
Front VGA assembly replacement . . . . . . 76
LOM adapter replacement . . . . . . . . . 80
M.2 drive and backplane replacement . . . . 83
Memory module replacement . . . . . . . 89
Operator panel tray assembly and front
operator panel replacement . . . . . . . . 92
PCIe riser card assembly and adapter
replacement . . . . . . . . . . . . . . 97
Power supply unit replacement . . . . . . . 106
Processor and heat sink replacement . . . . 112
Processor and memory expansion tray
replacement . . . . . . . . . . . . . . 121
Security bezel replacement . . . . . . . . 126
System board air baffle and the power
interposer replacement . . . . . . . . . . 128
System board replacement . . . . . . . . 132
TCM/TPM adapter replacement (for China
only) . . . . . . . . . . . . . . . . . 143
Top cover replacement . . . . . . . . . . 146
Replace components in the PCIe expansion
tray . . . . . . . . . . . . . . . . . . . 149
PCIe expansion tray replacement . . . . . . 149
4U PCIe riser assembly replacement . . . . . 152
4U PCIe riser card replacement . . . . . . . 155
4U PCIe riser power cable assembly
replacement . . . . . . . . . . . . . . 159
PCIe adapter replacement . . . . . . . . . 162
Complete the parts replacement . . . . . . . . 166
Chapter 4. Problem
determination . . . . . . . . . . . . . 167
Event logs . . . . . . . . . . . . . . . . . 167
Light path diagnostics . . . . . . . . . . . . 169
Power supply LEDs . . . . . . . . . . . 170
General problem determination procedures . . . . 171
Resolving suspected power problems . . . . 172
Resolving suspected Ethernet controller
problems . . . . . . . . . . . . . . . 172
Troubleshooting by symptom . . . . . . . . . 173
Drive problems . . . . . . . . . . . . . 173
Fan problems . . . . . . . . . . . . . . 177
Intermittent problems. . . . . . . . . . . 177
Keyboard, mouse, or USB-device
problems . . . . . . . . . . . . . . . 178
Memory problems . . . . . . . . . . . . 179
Monitor and video problems . . . . . . . . 180
© Copyright Lenovo 2018 i