Multiplex FreshBlender User Manual

Part Number: WBL-95-156 REV002 61
Section 4 Maintenance
Ice Machine Cleaning
OVERVIEW
You are responsible for maintaining the ice machine
in accordance with the instructions in this manual.
Maintenance procedures are not covered by the warranty.
• Sanitizing is recommended every three (3) months.
• Descaling is recommended every six (6) months.
More frequent descaling may be required in some existing
water conditions. Follow carefully any instructions provided
with the descaling or sanitizing solutions being used.
Important
Only a trained manager or authorized technician should
perform ice machine cleaning.
n
Warning
Always wear liquid-proof gloves to prevent the descaling
and sanitizing solutions from coming into contact with skin.
n
Warning
To prevent injury, disconnect main supply power to the
dispenser (when used) before cleaning or sanitizing the
bin area and dispenser parts.
Items Required
• Gloves
• Spray Bottle of Sanitizer Solution
• Clean & Sanitized Towels/Cloths
• Bottle Brush”
• Clean 5 Gallon Bucket
• Clean Pitcher or Cups
APPROVED SANITIZERS
• QUAT (Quaternary Ammonium) sanitizer such as Clean Quick®
• Stera‐Sheen® Green Label Sanitizer/Cleaner
• KAY-5® Green Label Sanitizer/Cleaner
Unit Preparation
Important
Keep refrigeration cabinet door closed so that product
remains chilled while the unit is OFF. If the unit will be
powered down for extended periods of time remove
the product bins and place in separate refrigerator to
prevent them from getting warm.
FULL ICE MAKER SANITIZING
To be done every six (6) months.
Important
Only a trained manager or authorized technician should
perform ice machine sanitizing.
1. Disconnect the water supply line quick connect in the
back of the unit.
Plain
Water IN
Rear of the Unit
2. Remove the left side and top panels from the unit to
gain access to the reservoir, ice dispense motor, and bin.
3. Mix approved sanitizing solution to the correct ratio.
Amount of Luke Warm
Water
Amount of Sanitizer
5 gallons (20 Liters)
(10 gallons (40 Liters)
may be needed to full
submerse removed parts)
Approved QUAT (Quaternary
Ammonium) sanitizer solution providing
300 ppm minimum such as clean quick®
mixed 1.5 oz per 5 gallons or Solution
that provides 100 ppm available Chlorine
minimum, consult manufacturer’s
instructions for ratio or 1/4 ounce (15 ml)
household bleach per gallon.
n
Warning
Always wear liquid-proof gloves to prevent the sanitizing
solution from coming into contact with skin.
4. Fill Spray bottle with portion of sanitizer solution from
the bucket. Set aside for later use.

Multiplex FreshBlender Specifications

General

Brand	Multiplex
Model	FreshBlender
Category	Dispenser
Language	English