Quadra-Fire CASTILE - Table of Contents; Safety Alert Key

R
October 27, 2011
Page3
Castile & Santa Fe CE Insert
7069-101B
TABLE OF CONTENTS
Safety Alert Key:
• DANGER! Indicatesahazardoussituationwhich,ifnotavoidedwillresultindeathorseriousinjury.
• WARNING!Indicatesahazardoussituationwhich,ifnotavoidedcouldresultindeathorseriousinjury.
• CAUTION! Indicatesahazardoussituationwhich,ifnotavoided,couldresultinminorormoderateinjury.
• NOTICE:Indicatespracticeswhichmaycausedamagetotheapplianceortoproperty.
Congratulations...............................................................2
SampleofSafety/SerialNumerLabel.............................2
SafetyAlertKey...............................................................3
LimitedWarranty.............................................................4-5
Section 1: Listing and Code Approvals
 A. ApplianceCertications.....................................6
 B. GlassSpecications..........................................6
 C. ElectricalRating................................................6
 D. Specications....................................................6
User’s Guide
Section 2: Operating Instructions
 A. FireSafety.........................................................7-8
 B. Combustible/Non-CombustibleMaterial............8
 C. FuelMaterial&FuelStorage............................8
 D. GeneralOperationInformation..........................9
 E. BeforeYourFirstFire........................................9
 F. FillingtheHopperwithFuel...............................9
 G. StartingYourFirstFire......................................10
 H. FireCharacteristics...........................................10
 I. FlameHeightAdjustment(FeedRate)..............10
 J. IgnitionCycles...................................................11
 K. ClearSpace......................................................11
Section 3: Maintaining & Servicing Appliance
A. ProperShutdownProcedures...........................12
 B. QuickReferenceMaintenanceChart................12
C. GeneralMaintenance&Cleaning.....................12-15
 D. HighAshFuelContentMaintenance................16
Section 4: Troubleshooting for Homeowner
 A. FrequentlyAskedQuestions.............................17
Installer’s Guide
Section 5: Getting Started
 A. Design,Installation&Location
  ConsiderationsandFloorSupport....................18
 B. ThermostatLocation.........................................19
 C. Tools&SuppliesNeeded..................................19
 D. InspectApplianceandComponents.................19
 E. Pre-BurnChecklist............................................19

Section 6: Dimensions & Clearances
 A. ApplianceDimensions.......................................20
 B. ClearancetoCombustibles,
  Masonry&ZeroClearance...............................21
 C. MinimumOpeningforMasonryand
  Factory-BuiltFireplace......................................21
D. FloorProtection.................................................21
 E. PrefabricatedMetalChimney............................21
Section 7: Vent Information
 A. VentingTerminationRequirements...................22
 B. AvoidingSmokeandOdors..............................22-23
 C. NegativePressure.............................................23
 D. Draft
..................................................................23
 E. Chimney&ExhaustConnection.......................24
 F. PelletVentingCharts........................................25
Section 8: Vent Systems
 A. FullRelinewithOutsideAir-Horizontal..............26
 B. FullRelinewithoutOutsideAir-Vertical.............27

Section 9: Appliance Set-Up
 A. LevelingSystem................................................28
 B. OutsideAirInstallation......................................28
 C. DoorHandleRemoval.......................................29
 D. DoorRemoval...................................................29
 E. AdjustableHearthSupport................................29
 F. HearthSupport,StandardSurround.................30-31
 G. Surround&TrimSet,Econo.............................31
 H. SurroundCastTrimSet....................................32
 I. PanelandTrimSet...........................................33
 J. LogSetPlacement(Optional)...........................34
 K. ThermostatInstallation......................................35
 ContactInformation...................................................36