Quadra-Fire CASTILE - General Operating Information; Before Your First Fire; Filling the Hopper with Fuel

R
October 27, 2011
Page9
Castile & Santa Fe CE Insert
7069-101B
D. General Operating Information
1. Thermostat Calls For Heat
Theapplianceislikemostmodernfurnaces;whenthethermostat
callsforheat,yourappliancewill automaticallylightanddeliver
heat.
When the room is up to temperature and the thermostat is
satised,theredcalllightwillshutoffandtheappliancewillshut
down.Theredcalllightislocatedbehindtherightaccesspanel.
2. Heat Output Controls
T
his appliance is equipped with a heat output control switch
that has three settings or burn rates; low, medium and high.
Figure 9.1.
Theappliancewillturnonandoffasthethermostatdemands.
Whenthethermostatcallsforheat,theappliance willalways
startuponHigh.Afterburningapproximately4 minutes,the
appliance will then burn at the rate at which it was originally
set.Iftheapplianceissetatoneofthelowersettings,itwill
runquieterbuttakeslongertoheatupanareathanifitwere
setatahigherburnrate.
Regardlessoftheburnrate,whentheareaiswarmenoughto
satisfythethermostat,theappliancewillshutoff.
WARNING
FireHazard.
Keepcombustiblematerials,gasoline
andotherammablevaporsandliquids
clearofappliance.
• DoNOTstoreammablematerialsintheappliance’s
vicinity.
•
DONOTUSEGASOLINE,LANTERNFUEL,KEROSENE,
CHARCOALLIGHTERFLUIDORSIMILARLIQUIDSTO
STARTOR“FRESHENUP”AFIREINTHISHEATER.
• DONOTBURNGARBAGEORFLAMMABLEFLUIDS
SUCHASGASOLINE,NAPHTHAORENGINEOIL.
• DONOTUSECHEMICALSOFFLUIDSTOSTARTTHE
FIRE.
• Keepallsuchliquidswellawayfromtheheaterwhileitisin
use.
• Combustiblematerialsmayignite.
High
Med
Low
Reset
Button
E. Before Your First Fire
1. First,makesureyourappliancehasbeenproperlyinstalled
and that all safety requirements have been met.  Pay
particular attention to the fire protection, venting and
thermostatinstallationinstructions.
2. Doublecheckthattheashdrawerandreboxareempty!
3. Closethefrontdoor.
CAUTION
Tipofthermocouplemustbeincontactwiththe
insideendofthethermocouplecover.
Missedignitionscanoccur.
F. Filling the Hopper with Fuel
a. Openthehopperlidandpullthelidtowardsyou.
b. Donotoverllthehopper.Thelidmustbecompletely
closedtomaintainpropervacuumandforthefeedmotor
tooperate. Anerrormessagewill appear on the wall
controlifthelidisnotproperlyclosed.
c. Remove any sawdust or fuel from the lid gasket after
rellinghopper.
d. Donotleaveanypartofthefuelbagontheappliance
afterrellinghopper.
e. Storefuelawayfrom theappliancetomaintainproper
safeairclearancetocombustibles.
Figure 9.1