Rosco Maximizer 2B User Manual

2
Rosco Maximizer 2B Asphalt Distributor 2-3
Safety
• Safety signs and labels are additional reminders for
safe operating and maintenance techniques.
• Makesureyouareawareofalllawsandregulations
that are in effect where the machine is operated.
Ensure you have all necessary licenses to operate the
machine.
• Before starting or operating the machine, ensure all
controls are OFF or in neutral position.
• Knowandunderstandthejobsitetrafcowpatterns
andobeyagmen,roadsignsandsignals.
Starting and Stopping
• Walkaroundthemachineandwarnallpersonnelin
the area before starting the machine. Be sure the
area is clear before starting. Death or serious injury
can occur to bystanders from being crushed under a
moving machine or being hit by material.
• Alwaysparkthemachineonlevelgroundwhenever
possible.Applytheparkingbrake.Ongrades,parkthe
Distributorwiththewheelssecurelyblocked.
• Stopping distances must be anticipated for all
conditions. If stopping on a grade, the distance
needed to come to a stop will be longer. Familiarize
yourself with these variables so you can anticipate
when a longer stopping distance is required.
The safety messages that follow have DANGER level
hazards.
Burner Operation
• Never operate burner equipment when the vehicle is
beingloadedorintransit.Theuetubescanbecome
exposed,causinganexplosioninsidethetank,or
ignite material being sprayed.
• Neveroperatetheburnersiftheuetubesarenot
covered with at least 8 inches (20.32 cm) of material.
Theuetubescanbecomeredhotandignitethe
vapors causing an explosion.
• Alwaysparkthetrucksothattheburnersareupwind.
Someasphaltmaterialsemitammablevaporsfrom
theventthatcanbeignitedbytheburnerameand
cause an explosion.
• Neveroperatetheburnersinaconnedareasuch
as a building or shed. Vapor build-up could cause an
explosion.
• Donotoperatetheburnersifthetankisleakingora
spill has occurred. Fire and explosion can occur.
• Keepthetankventscleartoavoidabuildupof
pressureinthetankwhenheating.Checkthevents
before starting the burners.
• Never use gasoline, alcohol or any other unapproved
fuel in a diesel burner. Fire and explosion can occur.
• Do not operate the burners while the wash down
system is operating or has recently been used. Fire
and explosion can occur.
• Donotoperatetheburnerswithtoptankcoveropen.
Fire and explosion can occur.
• Be sure to read, understand and follow all precautions
for the type of cleaning material you are using.
The safety messages that follow have WARNING
level hazards.
Crush Hazard
Keepbystandersawayfromworkareabeforeand
during operation.
Modification Hazard
Never modify the Rosco Maximizer 2B Asphalt
Distributor without written consent of LeeBoy. Any
modicationcanaffectthesafeoperationofthe
machine and may cause personal injury or death.
Exposure Hazard
Always wear personal protective
equipment, including appropriate clothing,
gloves,workshoes,andeyeandhearing
protection,asrequiredbythetaskathand.
Explosion Hazard
While the engine is running or the battery is
charging, hydrogen gas is being produced
and can be easily ignited. Keep the area
aroundthebatterywell-ventilatedandkeep
sparks,openameandanyotherformof
ignition out of the area.
• Always disconnect the negative (-) battery cable
before servicing the machine.
• Do not start the engine by shorting the starter circuit
or by using any other starting method not stated in this
manual. Only use the starting procedure as described
in this manual to start the engine.
• Never charge a frozen battery. Always slowly warm the
battery to room temperature before charging.
Return to
Last Viewed
Return to
Thumb Index

Rosco Maximizer 2B Specifications

General

Brand	Rosco
Model	Maximizer 2B
Category	Construction Equipment
Language	English