Surefire PumpRight D70 - Default Chapter; Table of Contents

396-3815Y1 SureFire PumpRight for Raven RCM Revised 01/16/2018
Table Of Contents
A
Introduction
Introduction
 Basic Steps to Install your Fertilizer System ..................................................... 2
 Complete Fertilizer System Example Drawing .................................................. 3-4
B
Components
Liquid
Components - Liquid
 Flowmeters, Section Valves .............................................................................. 5-6
 Pressure Sensor, Pump Priming and Air Bleed Valve ...................................... 7-8
 Recirculation & Agitation ................................................................................... 9
 Flow Indicators and Manifolds, Check Valves, Orifice Charts ........................... 10-16
 Dual Check Valve Systems, Row Distribution ................................................... 18-21
D
Components
Wiring & Elec.
Components - Wiring & Electrical
 Connecting to Raven RCM ............................................................................... 22-23
 Sample Harness Layouts .................................................................................. 24-25
 Harness Drawings .......................................................................................................... 26-34
E
Installation
Overview
Installation Overview
 Floating Ball Flow Indicators, PumpRight Installation ....................................... 35-36
 Hydraulic Connections, PWM Valve, Hydraulic Oil Flow Requirements ........... 37-39
 Liquid Plumbing Connections ............................................................................ 40-41
F
Setup &
Operation
Setup & Operation
 RCM Setup, Profile, Application Type ............................................................... 42
 Section Setup, Pressure Sensor, RPM Sensor ................................................ 43
 Control Valve Setup, Rate Sensor, Flow Cal, Fill Flowmeter, Rates ................ 44
 Pressure Sensor Setup/Calibration, Pump RPM .............................................. 45
 Advanced Tuning (not necessary for hydraulic pump systems) ........................ 46
 Height Switch, Display Setup, Menus ............................................................... 47
 System Enable/Disable (ON/OFF), MANUAL and AUTO Mode ....................... 48
 Initial Operation, Manual Operation, Auto Mode Test ....................................... 48
 Diagnostics, System Information, Tests ............................................................ 49
H
Maintenance
& Parts
Maintenance & Parts
 Air Bladder, Winterization, Pump Oil, Diaphragm and Valve Replacement. ..... 56
 Pre-season Service ........................................................................................... 57
 Replacing Valves and Diaphragms ................................................................... 58
 Diaphragm Pump Parts Information .................................................................. 59-65
 PWM Valve and Motor Parts ............................................................................. 66
G
Trouble-
Shooting
Troubleshooting
 Troubleshooting Tips ......................................................................................... 50
 Pump Will Not Turn, Hydraulic Manual Override .............................................. 51
 Rate Fluctuates or Slow Getting to Target Rate ............................................... 52
 Flowmeter Tap Test, Section Valves Won’t Move, Pressure Sensor ................ 53
 More Troubleshooting Suggestions and Help ................................................... 54-55
QuickStart Setup Sheet See the sheet for your harness, profile, and product setup
©2010-2018 SureFire Ag Systems—All Rights Reserved
SureFire Ag Systems