Chapter 6
Electrical System
Table of Contents
WIRING SCHEMATICS . . . . . . . . . . . . . . . . . . . . . . 2
Reelmaster 216
(S/N 99999 & Below). . . . . . . . . . . . 2
Reelmaster 216
(S/N 10001 – 19999) . . . . . . . . . . . . 3
Reelmaster 216
(S/N 20001 & Up) . . . . . . . . . . . . . . 4
Reelmaster 216-D . . . . . . . . . . . . . . . . . . . . . . . . 5
SPECIAL TOOLS . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
TROUBLESHOOTING
(Reelmaster 216) . . . . . . . . . . . 8
Starting Problems . . . . . . . . . . . . . . . . . . . . . . . . 8
General Run and Transport Problems. . . . . . . . . 11
Cutting Operation Problems . . . . . . . . . . . . . . . 12
Verify Interlock Operation . . . . . . . . . . . . . . . . . 13
TROUBLESHOOTING
(Reelmaster 216-D) . . . . . . . . . 14
Starting Problems . . . . . . . . . . . . . . . . . . . . . . . 14
General Run and Transport Problems. . . . . . . . 17
Cutting Operation Problems . . . . . . . . . . . . . . . 18
Verify Interlock Operation . . . . . . . . . . . . . . . . . 19
TESTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
Ignition Key Switch . . . . . . . . . . . . . . . . . . . . . . 20
Seat Switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Traction (Neutral) Switch . . . . . . . . . . . . . . . . . . 22
Cutting Unit Interlock Switch . . . . . . . . . . . . . . . 22
Cutting Unit Clutch (Reel Drive) Switch . . . . . . 23
Start and High Temp. Relays
(Reelmaster 216-D only) . . . . . . . . . . . . . . . . . . . . 24
Glow Plugs
(Reelmaster 216-D only) . . . . . . . . . . . . 25
Battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Injection Pump (ETR) Solenoid
(Reelmaster 216-D only) . . . . . . . . . . . . . . . . . . . . 26
Indicator Lights and Gauges . . . . . . . . . . . . . . . 27
High Temperature Shut-Down Switch
(Reelmaster 216-D only) . . . . . . . . . . . . . . . . . . . . 28
Temperature Gauge Sender
(Reelmaster 216-D only) . . . . . . . . . . . . . . . . . . . . 28
Engine Oil Pressure Switch
(Reelmaster 216-D only) . . . . . . . . . . . . . . . . . . . . 29
Starter Solenoid
(Reelmaster 216 only). . . . . . . . . . . . . . . . . . . . . . 30
Cutting Unit Clutch. . . . . . . . . . . . . . . . . . . . . . . 30
Interlock Module
(Reelmaster 216 only). . . . . . . . . . . . . . . . . . . . . . 30
REPAIRS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
Battery Service . . . . . . . . . . . . . . . . . . . . . . . . . 31
Fuses. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
Traction (Neutral) Switch Replacement . . . . . . . 33
Cutting Unit Interlock Switch Replacement . . . . 34
Reelmaster
®
216/216-D Page 6 - 1 Table of Contents