Lubricator Operating manual
Revision: 02
2022-D064493
en-4
2 Safety
It is imperative that all persons who work with the lubricator follow this manual, in particular the safety
instructions, as well as the rules and regulations applicable to the place of use.
In addition to the safety instructions shown in this manual, the generally applicable legal and other rules
and regulations for the prevention of accidents (e.g. personal protective equipment) and the protection
of the environment must be obeyed.
2.1 EC/EU directive
Within the scope of the EC/EU directive, initial operation is forbidden until such time as it has been
determined that the machine into which this lubricator is installed conforms to the requirements of this
directive.
An EC/EU declaration of conformity for this lubricator can be found in the appendix
(see section „10.2 Declaration of conformity”).
2.2 Hazards
In order to avoid hazards for the user or damage to the machine, the lubricator may be used only for its
intended use (see section „2.4 Intended use“) and only if it is in perfect working order.
Before commencing work, read the general safety instructions
(see section „2.7 General safety instructions“).
2.3 Personnel
Only qualified personnel who have read and understood this manual may work on the lubricator.
2.4 Intended use
Adhere to the following points in order to use the lubricator as it was intended:
• The lubricator is approved only for industrial use.
• The lubricator may be used only in accordance with the technical data
(see section „3.4 Technical data“).
• Unauthorized structural modifications to the lubricator are not permitted.
• Read the operating manual and act accordingly.
• During the operation of the lubricator a visual inspection of both the lubricator and the lubrication
point is to be carried out regularly. Any abnormalities are to be rectified immediately!
• Cartridge refill is not permitted.
• Use only lubricants that have been approved by the manufacturer.
• Obey the regulations for occupational health and safety and the prevention of accidents.
• Work with and on the lubricator only with the appropriate authorization, see section „2.3 Personnel“.
• All other types of use or the disregard of any of these points are regarded as inappropriate.
In this case no liability can be accepted and/or warranties given.
2.5 Reasonably foreseeable misuse
Any use that extends beyond the maximum permitted technical data is regarded as inappropriate and
is therefore forbidden.
To Next Page
Loading...