26
and modification, misuse, negligence, accident, over-
loading, over speeding, improper maintenance, repair
or storage so as, in our judgment, to adversely affect
its performance and reliability. This warranty also does
not cover normal maintenance such as adjustments,
fuel system cleaning and obstruction (due to chemical,
dirt, carbon, lime, and so forth).
• Other Exclusions: This warranty excludes wear items
such as oil gauges, o-rings, filters, fuses, or injectors etc.,
or damage or malfunctions resulting from accidents,
abuse, modifications, alterations, or improper servicing
or freezing or chemical deterioration. Accessory parts
are excluded from the product warranty. This warran
-
ty excludes failures due to acts of God and other force
majeure events beyond the manufacturer’s control.
14. GENERAL PRECAUTION
Dear AKSA generator set operator. Please take care
to the following order to prevent the generator set
warranty to become invalid if the warranty period and
to ensure trouble-free operation of the generator set
with a long life.
1. Maintenance and repair works will not be covered
by the warranty certificate. If the invoice or delivery
certificate of the generating set is not submitted.
2. The warranty of the generator set will become inval
-
id in case of any intervention of any person other than
authorized AKSA services or by prior written approval
from AKSA power generation on the generator set
for any reason.
3. Control and maintenance works indicated in the
periodical maintenance schedule and the operating
manual must be carried out completely and timely the
failures due to incomplete or untimely maintenance
are not covered by the warranty.
4. Generator set should be installed as indicated in the
installation manual otherwise, the problems which are
likely to occur will not be covered by the warranty.
5. Customer is responsible for the failures which are
likely to occur in case that the diesel oil used contains
dirt or water.
6. The oil type indicated in the maintenance manual
should be used in the engine otherwise, the failures
which are likely to occur will not be covered by the
warranty.
7. Batteries will not be covered by the warranty if they
are subjected to breakage, excessive acid fill or hard
-
ening by leaving uncharged.
8. Don’t over crank the generator set , if the generator
is not started at the first attempt , wait 10 second and
then try to start the engine again , the cranking mustn’t
be done more than 3 times ,and cranking time have to
be less than 10 seconds ,otherwise starter gear could
be broken or starter could be burn up. These condi
-
tions are not covered warranty.
9. Generator sets, never start or stop the diesel engine
when the generating set is under load. Engine should
be started and stopped after load is disconnected and
the generating set is at idle condition. Otherwise, the
valves can be seized, the voltage regulator, transformer
and diodes can be broken down. These conditions are
not covered warranty.
10. Our company does not take the responsibility of
the damages of the automatic generator sets due to
over current, low or high voltage.
11. Never remove the battery terminals while the gen
-
erating set is in use. Even a moment of disconnection
can cause damage on the electronic closing relay of the
charge alternator and on the electronic engine speed
control circuit these conditions are not covered by the
warranty.
12. Failures due to overload and unbalanced load in
excess of the generating set power (such as alternator
and contactor failures) are not covered by the war
-
ranty.
13. When the manually operated generating set is
started up, it should be warmed by operating at idle for
To Next Page
