Argo 8x8 Response User Manual

42
SECTION 7
MAINTENANCE INFORMATION
The intervals shown on the schedule are based on average operating conditions. Vehicles which are subjected to severe
use and wet or dusty conditions will require more frequent servicing. Use only Argo replacement parts to ensure safe
operation of the vehicle and to comply with the warranty coverage.
We strongly recommend that an Argo Dealer perform a complete check-over of your vehicle after the initial
20 hours of operation, then once each year. This will reduce maintenance costs over the life of your vehicle.
CHECK COOLANT LEVEL (Conquest & Avenger)
CHECK FAN BELT TENSION (Conquest & Avenger)
CHECK FUEL LEVEL
CHECK TIRE INFLATION
CHECK TWIST GRIP THROTTLE OPERATION
CHECK STEERING LEVER TRAVEL
CHECK ENGINE INTAKE/EXH. FOR OBSTR.
CHECK THAT DRAIN PLUGS ARE IN PLACE
CHECK ENGINE OIL LEVEL
CHANGE ENGINE OIL & OIL FILTER
- KAWASAKI & KOHLER
- BRIGGS & STRATTON
CHECK TRANSMISSION OIL LEVEL
CHANGE TRANSMISSION OIL
CLEAN AIR PRE-CLEANER (Briggs & Kaw. only)
CHECK CLEAN/REPLACE AIR FILTER
REPLACE FUEL FILTER
LUBRICATE DRIVEN CLUTCH
SERVICE DRIVER & DRIVEN CLUTCH
LUBRICATE DRIVE CHAINS
REMOVE, CLEAN & LUBE DRIVE CHAINS
LUBRICATE IDLER CHAINS
REMOVE, CLEAN & LUBE IDLER CHAINS
LUBRICATE AXLE FLANGE - OUTER CAVITY
LUBRICATE AXLE FLANGE - INNER CAVITY
LUBRICATE INNER AXLE BEARINGS
LUBRICATE IDLER BEARINGS
LUBRICATE STEERING LEVERS
CHECK BATTERY FLUID LEVEL & CAPS
CLEAN BATTERY TERMINALS & CONNEC.
CLEAN BATTERY
CLEAN, ADJUST/REPLACE SPARK PLUGS
CHECK THE DRIVE BELT
CHECK NYLON SLIDERS - DRIVEN CLUTCH
CHECK SLIDERS - CHAIN TAKE-UP SYSTEM
CHECK & ADJUST IDLER CHAINS
SERVICE THE CLUTCH UNITS
INSPECT BRAKE PADS
ADJUST HOLDING BRAKE
CHECK HYD. BRAKE FLUID LEVEL/COND.
CHECK FUEL TANK CONNECTIONS/LINES
INSPECT WIRING HARNESS
TIGHTEN BEARING EXT. BOLTS
CLEAN OUT SPARK ARRESTER
X
X
X 2.2
X 7.2.6
X 2.2
X 2.2
X 2.2
X 5.6
X 6.1.1
X X 6.1.3
X X 6.1.3
X X 6.2.1
X X 6.2.2
X 6.3.1
X 6.3.1
X 6.3.2
X 6.4.2
X 6.4.2
X 6.4.3
X 6.4.3
X 6.4.4
X 6.4.4
X 6.4.5
X 6.4.5
X 6.4.7
X 6.4.6
X
X 7.1.2
X 7.1.2
X 7.1.2
X 7.1.4
X 7.2.1
X 7.2.2
X X X 7.2.4
X X 7.2.5
X 6.4.2
X 7.3.1
X 7.3.5
X 7.4.2
X
X
X X 7.2.8
X 7.1.5
BEFORE
EACH
USE
AFTER INITIAL
EVERY
SECTION
REF.
2hrs. 8hrs. 20hrs. 10hrs. 25hrs. 50hrs. 100hrs.250hrs.

Argo 8x8 Response Specifications

General

Brand	Argo
Model	8x8 Response
Category	Utility Vehicle
Language	English