7-44 2003 Buell P3: Electrical
HOME
BATTERY 7.16
GENERAL
11WARNING1WARNING
All batteries contain electrolyte. Electrolyte is a sulfuric
acid solution that is highly corrosive and can cause
severe chemical burns. Avoid contact with skin, eyes,
and clothing. Avoid spillage. Always wear protective face
shield, rubberized gloves and protective clothing when
working with batteries. See Figure 7-58. A warning label
is attached to the top of the battery. Never remove warn-
ing label from battery. Failure to read and understand all
precautions contained in warning label before perform-
ing any service on batteries could result in death or seri-
ous injury. See Figure 7-59.
All 2003 Model Year Buell batteries are permanently sealed,
maintenance-free, valve-regulated, lead/calcium and sulfuric
acid batteries. The batteries are shipped pre-charged and
ready to be put into service. Do not attempt to open these
batteries for any reason.
Table 7-18. Battery Electrolyte Antidotes
CONTACT SOLUTION
External Flush with water.
Internal Drink large quantities of milk or water,
followed by milk of magnesia, vegetable oil
or beaten eggs. Call doctor immediately.
Eyes Flush with water, get immediate medical
attention.
Figure 7-58. Maintenance-Free AGM Battery
with Battery Warning Label
x0297x7x
Figure 7-59. Battery Warning Label
x0487x7x
1. Contents are corrosive
2. Wear safety glasses
3. Contents are explosive
4. Keep flames away
5. Read instructions
6. Keep away from children
65
4
32
1
To Next Page
Loading...
