CITROEN C3 2003 - Page 242

To Next Page

To Previous Page

238

INJECTION

AIR SUPPLY CIRCUIT SPECIFICATION

Lower integrated air inlet distributor.

The lower integrated air inlet system is composed of the following elements:

(7) Top EGR pipe.

(8) Inlet manifold.

(9) Diesel fuel filter with reheater and water detector (according to country).

(10) Diesel fuel filter support.

(11) Oil trap.

(12) Oil filler cap.

B1HP1JND

Engines : 8HX - 8HW

Main Page

Reconnect Battery after Vehicle Repair4
Identification of Vehicles - SAXO - All Types5
Identification of Vehicles - C3 - All Types9
Identification of Vehicles - XSARA - All Types16
Identification of Vehicles - XSARA PICASSO - All Types31
Identification of Vehicles - BERLINGO - All Types33
Capacities37
Draining Method37
Capacities - SAXO - All Types38
Capacities - C3 - All Types39
Capacities - XSARA - All Types40
Capacities - XSARA PICASSO - All Types41
Capacities - BERLINGO 2 - All Types42
Lubricants - Total Recommended Oils43
Engine Oil Norms44
ACEA 2003/API Norms45
Recapitulation47
Oil Usage Table49
Selection of Total Engine Oils, to be Used According to the Climatic Conditions50
Engine Oils - France51
Engine Oils - Europe52
Engine Oils - Oceania/Africa58
Engine Oils - Central and South America59
Engine Oils -South East Asia60
Engine Oils - Middle East62
Gearbox Oils63
Engine Coolant Fluid64
Power Steering Oils64
Brake Fluid65
Hydraulic Circuit65
Screen Wash Fluid66
Grease66
Engine Oil Consumption67
Engine Specifications HFX - KFW - NFT - NFV68
Engine Specifications NFX - NFU - 6FZ - RFN - RFS69
Engine Specifications VJX - 8HX - 8HW - 8HV - 8HY - 8HZ70
Tightening Torques71
All Types72
RH Engine Support/Lh Engine Support on Gearbox73
Torque Reaction Rod73
Table of Contents74
Tightening Torques Crankshaft/Cylinder Block/Head74
Tightening Torques Flywheel/Clutch/Lubrication and Cooling Circuit75
Tightening Torques Engine 8HX - 8HW76
Timing Belt Tensioner Roller 277
Coolant Outlet Housing79
Tightening 279
Tightening Torques Engines 8HY - 8HV80
Angular Tightening 4481
Inlet Manifold81
Exhaust Manifold 1.781
Cylinder Block81
- Tightening Torques Engines : RFS - VJX83
- Cylinder Head SAXO - XSARA PICASSO84
- Cylinder Head C386
- Cylinder Head XSARA - C390
- Cylinder Head XSARA PICASSO91
- Cylinder Head XSARA95
- Cylinder Head XSARA - XSARA PICASSO98
- Belt Tension/Seem Units Correspondence Table100
- Auxiliary Equipment Drive Belt101
- Auxiliary Equipment Drive Belt SAXO104
- Auxiliary Equipment Drive Belt C3105
- Auxiliary Equipment Drive Belt XSARA PICASSO107
- Auxiliary Equipment Drive Belt XSARA109
- Auxiliary Equipment Drive Belt SAXO - XSARA110
- Auxiliary Equipment Drive Belt XSARA - XSARA PICASSO114
- Checking and Setting the Valve Timing128
- Checking and Setting the Valve Timing SAXO - XSARA130
- Checking and Setting the Valve Timing C3133
- Checking and Setting the Valve Timing SAXO147
- Checking and Setting the Valve Timing XSARA - XSARA PICASSO167
- Checking and Setting the Valve Timing XSARA186
- Old/New Fitting201
- Special Features of the Timing - XSARA210
- Camshaft Hub Identification210
- Valve Clearance Settings211
- Checking the Oil Pressure212
- Oil Filters213
- Filling and Bleeding the Cooling Circuit214
- Idling/Depollution SAXO - C3 - XSARA PICASSO215
- Petrol Injection SAXO216
- Petrol Injection C3217
- Petrol Injection XSARA - XSARA PICASSO218
- Depollution Technical Checks (France)219
- Emission Standards220
- Safety Requirements: Hdi Direct Injection System XSARA - XSARA PICASSO226
- Cleanliness Requirements XSARA - XSARA PICASSO227
- Bosch Injection Pump Specifications SAXO228
- Checking and Setting the Bosch Mechanical Injection Pump SAXO230
- Fitting Bosch Injectors SAXO234
- Prohibited Operations: Siemens HDI Direct Injection System C3235
- Prohibited Operations: Delphi HDI Direct Injection System C3237
- Checks: Low Pressure Fuel Supply Circuit C3239
- Air Supply Circuit Specification C3241
- Checks: Exhaust Gases Recycling Circuit C3246
- Checks: Turbo Pressure C3247
- Specifications of the Delphi Diesel Injection Pump XSARA249
- Checking and Setting the Delphi Diesel Injection Pump XSARA251
- Adjusting the Mechanical Controls of the Delphi Injection Pump XSARA254
- Fitting Delphi Diesel Injectors XSARA256
- Injection Pump Specifications (Bosch and Siemens) XSARA PICASSO257
- Prohibited Operations: Hdi Direct Injection System XSARA PICASSO258
- Checks: Low Pressure Fuel Supply Circuit XSARA PICASSO260
- Checks: Air Supply Circuit XSARA PICASSO262
- Checks: Turbo Pressure XSARA PICASSO263
- Checks: Exhaust Gases Recycling Circuit XSARA PICASSO265
- Sparking Plugs266
- Speedometer267
- Clutch Specifications C3 - SAXO268
- Clutch Specifications C3269
- Clutch Specifications XSARA - XSARA PICASSO270
- Clutch Specifications BERLINGO271
- Lutch: Check and Adjustments SAXO - XSARA272
- Clutch: Checks and Adjustments XSARA276
- Clutch: Checks and Adjustments XSARA - XSARA PICASSO277
- Gearbox and Tyre Specifications SAXO278
- Gearbox and Tyre Specifications C3 - All Types279
- Gearbox and Tyre Specifications XSARA280
- Gearbox and Tyre Specifications XSARA PICASSO281
- Gearbox MA/5 SAXO - XSARA282
- Gearbox MA/5 - C3284
- Gearbox BE4/5 - C3 - XSARA - XSARA PICASSO291
- Gearbox Controls BE4/5 - C3 - XSARA - XSARA PICASSO292
- Gearbox BE4/5 - C3294
- Gearbox BE4/5 - XSARA - XSARA PICASSO295
- Gearbox Controls BE4/5 XSARA - XSARA PICASSO299
- BE4/5 Gearbox Checks and Adjustments XSARA - XSARA PICASSO300
- Automatic Gearbox MB3 SAXO302
- Recommendations and Precautions (Automatic Gearbox MB3) - SAXO303
- Special Features: Automatic Gearbox MB3 - SAXO306
- MB3 Automatic Gearbox Controls SAXO307
- MB3 Automatic Gearbox Controls - Checks and Adjustments - SAXO308
- Automatic Gearbox - AL4: C3 - XSARA - XSARA PICASSO309
- Recommendations - Precautions (Boite de Vitesses Automatique al 4) C3 - XSARA - XSARA PICASSO310
- Recommendations - Precautions (Automatic Gearbox al 4) XSARA - XSARA PICASSO317
- Driveshafts - Gearbox SAXO - C3 - XSARA - XSARA PICASSO318
- Axle Geometry SAXO - All Types319
- Axle Geometry321
- Front Axle SAXO All Types322
- Rear Axle SAXO All Types323
- Rear Axle Suspension SAXO All Types324
- Steering Specifications SAXO - All Types325
- Manual Steering SAXO - All Types326
- Power Assisted Steering SAXO - All Types327
- Axle Geometry C3330
- Front Axle C3333
- Rear Axle C3334
- Suspension C3335
- Features of Electric Power Steering C3338
- Special Features: Steering C3341
- Axle Geometry XSARA - All Types343
- Axle Geometry XSARA345
- Front Axle XSARA - All Types348
- Rear Axle XSARA - All Types351
- Rear Damper XSARA - All Types355
- Manual Steering Specifications XSARA - All Types356
- Power-Assisted Steering Specifications XSARA - All Types359
- Axle Geometry XSARA PICASSO - All Types363
- Front Axle XSARA PICASSO - All Types366
- Rear Axle XSARA PICASSO - All Types367
- Suspension XSARA PICASSO - All Types369
- Steering Column Specifications XSARA PICASSO - All Types371
- Steering Specifications XSARA PICASSO - All Types372
- Power-Assisted Steering Specifications XSARA PICASSO - All Types374
- Brake Specifications SAXO - All Types375
- Brakes SAXO - All Types377
- Handbrake Adjustment SAXO - All Types381
- Bleeding the Brakes SAXO382
- Brake Specifications (Without ABS) C3383
- Brake Specifications (with ABS) C3384
- Brake Specifications C3385
- Brake Specifications390
- Handbrake Adjustment C3391
- Bleeding and Filling the Braking System C3393
- Brake Specifications XSARA396
- Brake Specifications XSARA - All Types398
- Rear Brake Specifications XSARA - All Types407
- Check and Adjustments: Brake Compensator XSARA - All Types409
- Checking the Brake Pressure413
- Adjusting the Compensator414
- Handbrake XSARA - All Types415
- Bleeding the Brakes SAXO - All Types416
- Brake Specifications XSARA PICASSO - All Types417
- Checking and Adjusting the Load-Sensitive Brake Compensator XSARA PICASSO - All Types421
- Handbrake Adjustment - XSARA PICASSO - All Tpes428
- Bleeding the Brakes XSARA PICASSO - All Types429
- Starter Motors430
- Starter Motors SAXO432
- Starter Motors XSARA434
- Starter Motors XSARA PICASSO436
- Alternators437
- Alternators SAXO438
- Alternators C3440
- Alternators XSARA442
- Alternator XSARA PICASSO444
- Charging Circuit Alternator with Mono-Function Regulator446
- Pre-Heating and Starting Systems448
- Air Conditioning R134 a (HFC)449
- Air Conditioning System (R 134A) C3 - XSARA PICASSO451
- Pollen Filter454
- Changing the Filtering/Drying Cartridge455
- BEHR Plate Evaporator457
- Air Conditioning System XSARA - All Types458
- Air Conditioning System XSARA PICASSO459
- Compressor Lubricant461
- Checking the Compressor Oil Level462
- Air Conditioning System R 134.A Testing Procedure463
- Checking the Efficiency of the Air Conditioning System464
- Checking Pressures465
- Air Conditioning System SAXO - All Types466
- Checks on the Air Conditioning Circuit467
- Air Conditioning System C3468
- Air Conditioning System XSARA PICASSO TU478
- Air Conditioning System XSARA PICASSO EW7479
- Air Conditioning System XSARA PICASSO TU - EW7480
- Air Conditioning System XSARA PICASSO DW10481

CITROEN C3 2003 - Page 242

Table of Contents

Related product manuals