CITROEN C3 2003 - Tightening Torques Engines: RFS

To Next Page

To Previous Page

ENGINE

SPECIAL FEATURES - TIGHTENING TORQUES ( m.daN )

Engines : RFS - VJX

SAXO

VJX

- Pre-tighten 0.4

- Tighten to 0.7

XSARA

RFS

- Pre-tighten 0.5

- Tighten to 1

TUD - XU

B1DP03BC B1DP01YD

Main Page

Reconnect Battery after Vehicle Repair4
Identification of Vehicles - SAXO - All Types5
Identification of Vehicles - C3 - All Types9
Identification of Vehicles - XSARA - All Types16
Identification of Vehicles - XSARA PICASSO - All Types31
Identification of Vehicles - BERLINGO - All Types33
Capacities37
Draining Method37
Capacities - SAXO - All Types38
Capacities - C3 - All Types39
Capacities - XSARA - All Types40
Capacities - XSARA PICASSO - All Types41
Capacities - BERLINGO 2 - All Types42
Lubricants - Total Recommended Oils43
Engine Oil Norms44
ACEA 2003/API Norms45
Recapitulation47
Oil Usage Table49
Selection of Total Engine Oils, to be Used According to the Climatic Conditions50
Engine Oils - France51
Engine Oils - Europe52
Engine Oils - Oceania/Africa58
Engine Oils - Central and South America59
Engine Oils -South East Asia60
Engine Oils - Middle East62
Gearbox Oils63
Engine Coolant Fluid64
Power Steering Oils64
Brake Fluid65
Hydraulic Circuit65
Screen Wash Fluid66
Grease66
Engine Oil Consumption67
Engine Specifications HFX - KFW - NFT - NFV68
Engine Specifications NFX - NFU - 6FZ - RFN - RFS69
Engine Specifications VJX - 8HX - 8HW - 8HV - 8HY - 8HZ70
Tightening Torques71
All Types72
RH Engine Support/Lh Engine Support on Gearbox73
Torque Reaction Rod73
Table of Contents74
Tightening Torques Crankshaft/Cylinder Block/Head74
Tightening Torques Flywheel/Clutch/Lubrication and Cooling Circuit75
Tightening Torques Engine 8HX - 8HW76
Timing Belt Tensioner Roller 277
Coolant Outlet Housing79
Tightening 279
Tightening Torques Engines 8HY - 8HV80
Angular Tightening 4481
Inlet Manifold81
Exhaust Manifold 1.781
Cylinder Block81
- Tightening Torques Engines : RFS - VJX83
- Cylinder Head SAXO - XSARA PICASSO84
- Cylinder Head C386
- Cylinder Head XSARA - C390
- Cylinder Head XSARA PICASSO91
- Cylinder Head XSARA95
- Cylinder Head XSARA - XSARA PICASSO98
- Belt Tension/Seem Units Correspondence Table100
- Auxiliary Equipment Drive Belt101
- Auxiliary Equipment Drive Belt SAXO104
- Auxiliary Equipment Drive Belt C3105
- Auxiliary Equipment Drive Belt XSARA PICASSO107
- Auxiliary Equipment Drive Belt XSARA109
- Auxiliary Equipment Drive Belt SAXO - XSARA110
- Auxiliary Equipment Drive Belt XSARA - XSARA PICASSO114
- Checking and Setting the Valve Timing128
- Checking and Setting the Valve Timing SAXO - XSARA130
- Checking and Setting the Valve Timing C3133
- Checking and Setting the Valve Timing SAXO147
- Checking and Setting the Valve Timing XSARA - XSARA PICASSO167
- Checking and Setting the Valve Timing XSARA186
- Old/New Fitting201
- Special Features of the Timing - XSARA210
- Camshaft Hub Identification210
- Valve Clearance Settings211
- Checking the Oil Pressure212
- Oil Filters213
- Filling and Bleeding the Cooling Circuit214
- Idling/Depollution SAXO - C3 - XSARA PICASSO215
- Petrol Injection SAXO216
- Petrol Injection C3217
- Petrol Injection XSARA - XSARA PICASSO218
- Depollution Technical Checks (France)219
- Emission Standards220
- Safety Requirements: Hdi Direct Injection System XSARA - XSARA PICASSO226
- Cleanliness Requirements XSARA - XSARA PICASSO227
- Bosch Injection Pump Specifications SAXO228
- Checking and Setting the Bosch Mechanical Injection Pump SAXO230
- Fitting Bosch Injectors SAXO234
- Prohibited Operations: Siemens HDI Direct Injection System C3235
- Prohibited Operations: Delphi HDI Direct Injection System C3237
- Checks: Low Pressure Fuel Supply Circuit C3239
- Air Supply Circuit Specification C3241
- Checks: Exhaust Gases Recycling Circuit C3246
- Checks: Turbo Pressure C3247
- Specifications of the Delphi Diesel Injection Pump XSARA249
- Checking and Setting the Delphi Diesel Injection Pump XSARA251
- Adjusting the Mechanical Controls of the Delphi Injection Pump XSARA254
- Fitting Delphi Diesel Injectors XSARA256
- Injection Pump Specifications (Bosch and Siemens) XSARA PICASSO257
- Prohibited Operations: Hdi Direct Injection System XSARA PICASSO258
- Checks: Low Pressure Fuel Supply Circuit XSARA PICASSO260
- Checks: Air Supply Circuit XSARA PICASSO262
- Checks: Turbo Pressure XSARA PICASSO263
- Checks: Exhaust Gases Recycling Circuit XSARA PICASSO265
- Sparking Plugs266
- Speedometer267
- Clutch Specifications C3 - SAXO268
- Clutch Specifications C3269
- Clutch Specifications XSARA - XSARA PICASSO270
- Clutch Specifications BERLINGO271
- Lutch: Check and Adjustments SAXO - XSARA272
- Clutch: Checks and Adjustments XSARA276
- Clutch: Checks and Adjustments XSARA - XSARA PICASSO277
- Gearbox and Tyre Specifications SAXO278
- Gearbox and Tyre Specifications C3 - All Types279
- Gearbox and Tyre Specifications XSARA280
- Gearbox and Tyre Specifications XSARA PICASSO281
- Gearbox MA/5 SAXO - XSARA282
- Gearbox MA/5 - C3284
- Gearbox BE4/5 - C3 - XSARA - XSARA PICASSO291
- Gearbox Controls BE4/5 - C3 - XSARA - XSARA PICASSO292
- Gearbox BE4/5 - C3294
- Gearbox BE4/5 - XSARA - XSARA PICASSO295
- Gearbox Controls BE4/5 XSARA - XSARA PICASSO299
- BE4/5 Gearbox Checks and Adjustments XSARA - XSARA PICASSO300
- Automatic Gearbox MB3 SAXO302
- Recommendations and Precautions (Automatic Gearbox MB3) - SAXO303
- Special Features: Automatic Gearbox MB3 - SAXO306
- MB3 Automatic Gearbox Controls SAXO307
- MB3 Automatic Gearbox Controls - Checks and Adjustments - SAXO308
- Automatic Gearbox - AL4: C3 - XSARA - XSARA PICASSO309
- Recommendations - Precautions (Boite de Vitesses Automatique al 4) C3 - XSARA - XSARA PICASSO310
- Recommendations - Precautions (Automatic Gearbox al 4) XSARA - XSARA PICASSO317
- Driveshafts - Gearbox SAXO - C3 - XSARA - XSARA PICASSO318
- Axle Geometry SAXO - All Types319
- Axle Geometry321
- Front Axle SAXO All Types322
- Rear Axle SAXO All Types323
- Rear Axle Suspension SAXO All Types324
- Steering Specifications SAXO - All Types325
- Manual Steering SAXO - All Types326
- Power Assisted Steering SAXO - All Types327
- Axle Geometry C3330
- Front Axle C3333
- Rear Axle C3334
- Suspension C3335
- Features of Electric Power Steering C3338
- Special Features: Steering C3341
- Axle Geometry XSARA - All Types343
- Axle Geometry XSARA345
- Front Axle XSARA - All Types348
- Rear Axle XSARA - All Types351
- Rear Damper XSARA - All Types355
- Manual Steering Specifications XSARA - All Types356
- Power-Assisted Steering Specifications XSARA - All Types359
- Axle Geometry XSARA PICASSO - All Types363
- Front Axle XSARA PICASSO - All Types366
- Rear Axle XSARA PICASSO - All Types367
- Suspension XSARA PICASSO - All Types369
- Steering Column Specifications XSARA PICASSO - All Types371
- Steering Specifications XSARA PICASSO - All Types372
- Power-Assisted Steering Specifications XSARA PICASSO - All Types374
- Brake Specifications SAXO - All Types375
- Brakes SAXO - All Types377
- Handbrake Adjustment SAXO - All Types381
- Bleeding the Brakes SAXO382
- Brake Specifications (Without ABS) C3383
- Brake Specifications (with ABS) C3384
- Brake Specifications C3385
- Brake Specifications390
- Handbrake Adjustment C3391
- Bleeding and Filling the Braking System C3393
- Brake Specifications XSARA396
- Brake Specifications XSARA - All Types398
- Rear Brake Specifications XSARA - All Types407
- Check and Adjustments: Brake Compensator XSARA - All Types409
- Checking the Brake Pressure413
- Adjusting the Compensator414
- Handbrake XSARA - All Types415
- Bleeding the Brakes SAXO - All Types416
- Brake Specifications XSARA PICASSO - All Types417
- Checking and Adjusting the Load-Sensitive Brake Compensator XSARA PICASSO - All Types421
- Handbrake Adjustment - XSARA PICASSO - All Tpes428
- Bleeding the Brakes XSARA PICASSO - All Types429
- Starter Motors430
- Starter Motors SAXO432
- Starter Motors XSARA434
- Starter Motors XSARA PICASSO436
- Alternators437
- Alternators SAXO438
- Alternators C3440
- Alternators XSARA442
- Alternator XSARA PICASSO444
- Charging Circuit Alternator with Mono-Function Regulator446
- Pre-Heating and Starting Systems448
- Air Conditioning R134 a (HFC)449
- Air Conditioning System (R 134A) C3 - XSARA PICASSO451
- Pollen Filter454
- Changing the Filtering/Drying Cartridge455
- BEHR Plate Evaporator457
- Air Conditioning System XSARA - All Types458
- Air Conditioning System XSARA PICASSO459
- Compressor Lubricant461
- Checking the Compressor Oil Level462
- Air Conditioning System R 134.A Testing Procedure463
- Checking the Efficiency of the Air Conditioning System464
- Checking Pressures465
- Air Conditioning System SAXO - All Types466
- Checks on the Air Conditioning Circuit467
- Air Conditioning System C3468
- Air Conditioning System XSARA PICASSO TU478
- Air Conditioning System XSARA PICASSO EW7479
- Air Conditioning System XSARA PICASSO TU - EW7480
- Air Conditioning System XSARA PICASSO DW10481

CITROEN C3 2003 - Tightening Torques Engines: RFS - VJX

Table of Contents

Related product manuals