Dover OPW SiteSentinel iTouch M1500 - Page 97

127 pages

To Next Page

To Previous Page

Doc. No.: M1500 Rev. 5

Page 97 of 127

• 67733 Gross Point Road 900 Santa Fe Dr.

Doc. No.: M1500, Rev. 5

Page 97 of 127

67733 Gross Point Road 900 Santa Fe Dr.Doc. No.:

M1500, Rev. 5

Page 97 of 127

• 67733 Gross Point Road 900 Santa Fe Dr.

•

Communication Ports

Power Supply

The power supply board is separate.

Main Page

Table of Contents3
Introduction8
Warnings8
Safety8
Compliance8
Precision Leak Test8
Initial Inspection9
Connect Internal Battery9
Specifications10
Sitesentinel Itouch Controller10
Printer11
Magnetostrictive Probe (Model 924B)12
About the 924B Probe12
Probe Lengths/Installation Scenarios13
Controller Installation15
Mounting the Controller15
Mounting the Optional Printer Bracket16
Installing the Controller Power Supply Conduit17
Wiring the Controller Power Supply17
Grounding the Sitesentinel Itouch Tank Gauging System19
Sitesentinel Itouch Port Protection19
Preparing for Probe and Sensor Installation21
Probe and Sensor Wiring21
Compliance21
Wire Type21
Probe Wiring21
Sensor Wiring21
Wire Length21
Wire Splices21
Conduit22
Probe-Cable Seal-Offs23
Junction Boxes24
Preparing Your Tanks for Probes25
Underground Tank Manholes25
Precision Leak Test26
Probe Placement26
Product Float and Water Float Offsets27
Offset Procedure27
Float Offset Example27
Calculating Tank Tilt and Offset Factor28
Probes29
Probe Floats29
Probes Wiring37
Sensors39
Before You Begin39
30-3206 Interstitial Hydrocarbon Liquid/Water Sensor39
Installing the 30-320640
1St I.S. Module Position - Hydrocarbon Liquid41
2Nd I.S. Module Position - Water41
Testing and Decontaminating the Interstitial Hydrocarbon Liquid/Water Sensor41
30-3207 Hydrocarbon Liquid Sensor42
Installing the 30-320743
Controller Setup for Hydrocarbon Liquid Sensor44
Testing and Decontaminating the Hydrocarbon Liquid Sensor44
10, -15 Hydrocarbon Liquid/Water Sensor45
Installing the 30-321046
1St I.S. Module Position - Hydrocarbon47
Hydrocarbon Liquid/Water Sensor Test and Decontamination Procedures48
Hydrocarbon Liquid Sump Sensor49
Installing the 30-3219-1250
Controller Setup for Hydrocarbon Liquid Sump Sensor51
Testing and Decontaminating the Hydrocarbon Liquid Sump Sensor51
Single Level Sump Sensor52
Installing the 30-3221-153
Controller Setup for Single-Level Sump Sensor54
Testing the Single-Level Sump Sensor54
Dual Level Reservoir Sensor55
Installing the 30-3221-255
Testing the Dual-Level Reservoir Sensor Float57
30-3221-1A, -1B Interstitial Level Sensors58
Installing the 30-3221-1A, -1B59
Controller Setup for Interstitial Level Sensor60
Testing the Interstitial Level Sensor60
30-3222 Hydrocarbon Vapor Sensor61
Installing the 30-322262
Sitesentinel Itouch Controller Setup for Hydrocarbon Vapor Sensor63
Testing and Decontaminating the Hydrocarbon Vapor Sensor63
30-3223 Interstitial Optical Liquid Sensor64
Installing the 30-322365
Controller Setup for Interstitial Optical Liquid Sensor65
Testing the Interstitial Optical Liquid Sensor66
30-3224 Combo Single Level/Hydrocarbon Liquid Sump Sensor66
Installing the 30-322467
Testing the Float Sensor Portion of the Combo Sensor69
Testing and Decontaminating the Hydrocarbon Sensor Portion of the Combo69
Sensor69
30-3225 Combo Dual Level/Hydrocarbon Liquid Sump Sensor70
Installing the 30-322571
Controller Setup for 30-322572
Testing the Float Sensor Portion of the Combo Sensor73
Testing and Decontaminating the Hydrocarbon Portion of the Combo Sensor73
Testing the Water Sensor Portion of the Combo Sensor74
External Device Connection75
Communication Ports76
Terminal Block Detail77
Printer Option78
Modem Connections79
CAP Connection for Siteconnect Software80
POS Interface Option80
Built-In TCP/IP Connections80
Appendix A - LCD Screen Icons81
Appendix B - Alarm Kit Option82
Appendix C - POS Interface84
Appendix D - Upgrading Sitesentinel Itouch Software Via Siteconnect85
Appendix E - OM4 Output Module Option87
Appendix F - LPG Probe Option90
Appendix G - Probe Comparison94
Appendix H - Hardware for Sitesentinel Itouch Controller Main Board95
Dip-Switch98
Appendix J - EPA Certifications99
Appendix K Declaration of Conformity117
Appendix L - Itouch Control Drawing121

Dover OPW SiteSentinel iTouch M1500 - Page 97

Table of Contents

Related product manuals