Page 4 Panda_6000i_System_eng_s01835.book.R01 - Table of contents 16.1.09
Table of contents
C.4 The freshwater coolant circuit ....................................................................................... 37
C.4.1 Position of the external cooling water expansion tank ....................................................... 37
C.4.2 Pressure test for controlling the cooling water circuit ........................................................ 37
C.4.3 Scheme for freshwater circuit at two circuit cooling system .............................................. 38
C.5 Water-cooled exhaust system ....................................................................................... 39
C.5.1 Installation of the standard exhaust system ....................................................................... 39
C.5.2 Exhaust / water separator .................................................................................................. 40
C.5.3 Installation exhaust-water-separator .................................................................................. 41
C.6 Installation of the fuel system ....................................................................................... 43
C.6.1 General references ............................................................................................................ 43
C.6.2 The electrical fuel pump ..................................................................................................... 44
C.6.3 Connection of the fuel lines at the tank .............................................................................. 44
C.6.4 Position of the pre-filter with water separator .................................................................... 45
C.7 Generator 12VDC system installation ........................................................................... 46
C.7.1 Connection of the 12V starter battery ................................................................................ 46
C.7.2 Connection of the remote control panel - See Panda iControl panel manual .................... 46
C.8.1 Installation PMGi inverter - See separat PMGi 6000 inverter manual ............................... 48
D Generator Failure..........................................................................................................49
D.1 Tools and measuring instruments ................................................................................ 49
D.2 Overloading the generator ............................................................................................. 49
D.2.1 Low generator-output voltage ............................................................................................ 50
D.3 Starting problems ........................................................................................................... 50
D.3.1 Fuel solenoid valve ............................................................................................................ 50
D.3.2 Dirty fuel filter ..................................................................................................................... 51
D.4 Troubleshooting table .................................................................................................... 51
E Maintenance Instructions ............................................................................................53
E.1 General maintenance instructions ................................................................................ 53
E.1.1 Checks before starting ....................................................................................................... 53
E.1.2 Check of hoses and rubber parts in the sound insulated capsule ..................................... 53
E.2 Oil change intervals ........................................................................................................ 53
E.2.1 Execution of an oil change ................................................................................................. 54
E.3 Ventilating the fuel system ............................................................................................ 57
E.3.1 Replace of the fuel filter ..................................................................................................... 58
E.3.2 Checking the water separator in the fuel supply ................................................................ 59
E.4 Replace the air filter mat ................................................................................................ 60
E.5 Ventilation of the Coolant Circuit / Freshwater ............................................................ 61
E.6 Replace of the v-belt for the internal cooling water pump ......................................... 63
E.7 The Raw water circuit ..................................................................................................... 65
E.7.1 Clean raw water filter ......................................................................................................... 65
E.7.2 Reason for frequent impeller wear ..................................................................................... 65
E.7.3 Replace the impeller .......................................................................................................... 66
E.8 Conservation of the generator (long operation interruption) ..................................... 68
E.8.1 Measures for preparation of winter storage ....................................................................... 68
E.8.2 Initiation during spring ........................................................................................................ 69
F Tables ............................................................................................................................71
F.1 Troubleshooting ............................................................................................................. 71
To Next Page
Loading...
