Four winns FUNSHIP - Swivel.jack; Brake.actuator.&.Coupling.assembly; Winch; Lights

Owner’s Manual Page 126Trailer Information - Section S
G. Tie-downs
Replace frayed or damaged tie-downs. Periodically,
lubricatetheratchetmechanismwithaneoilor
silicone spray. Replacement parts may be ordered
through a Four Winns dealer.
H. Wheels
Somemaintenanceisrequiredtomaintainthenish
and retard rusting of painted rims. The wheels should
be cleaned with dishwashing soap and water and
rinsed with clean water immediately after each use.
Waxing is recommended three to four times each
year.
Aluminum wheel rims may be cleaned with dishwas-
hing soap and water. However, cleaning products
specicallyforaluminumareavailableandcanbe
used. Cleaners may be obtained from Four Winns
dealers and your local auto parts stores. The Mag
wheel manufacturer recommends a product by Prior-
ity One
®
called Pro-Long Aluminum/Chrome Wheel
Protectant™.Galvanizedrimsshouldberinsedonly
with clean water immediately after each use.
NOTICE
ALWAYS read the manufacturer’s instructions
on the label before using any product.
I. Brakes
Keep the actuator clean of dirt, tar, and mud. The
actuator and internal parts should be lubricated at all
times with SAE 30 weight oil. The hitch ball may be
lubricated with automotive grease or lubricant made
for hitch balls.
Periodically inspect the brake system for leaks.
Check all hoses for cuts or wear. Replace all defective
hoses.Themastercylindershouldbelledwithin1/2
inch from the top of the reservoir.
A
t the beginning of each year, inspect the brakes for
excessive wear, have linings replaced if necessary.
If the brakes need bleeding, consult your Four Winns
dealer for assistance. If unavailable, a brake or auto
repair facility can perform the repair.
Refer to the manufacturer’s literature included in the
owner’s packet for additional information on the brake
system.
C. Swivel Jack
Keep the swivel jack clean of dirt, tar, and mud.
Lubricate every six months. The swivel jack’s inner
ram should be lubricated with SAE 30 weight oil. The
top cover may be removed to lubricate the gears with
wheel bearing grease.
Replace all worn and damaged parts. ALWAYS use
the manufacturer’s replacement parts. Replacement
parts may be ordered through your Four Winns dealer.
For more information on maintenance, refer to the
manufacturer’s literature included in the owner’s
packet.
D
. Brake Actuator & Coupling Assembly
When storing or parking your trailer, keep the brake
actuator and coupling assembly (coupler) off the
ground to prevent dirt buildup in the ball socket. Keep
the coupler clean of dirt, tar, and mud. Lubricate the
coupler with SAE 30 weight oil every six months or as
often as necessary. Replace any worn or defective
parts. If the coupler is damaged, contact your Four
Winns dealer for replacement parts. DO NOT use a
damaged or bent coupler assembly. For more infor-
mation on maintenance, refer to the manufacturer’s
literature included in the owner’s packet.
NOTICE
The trailer should be set up at a slight angle to
allow for water to drain aft in the boat.
E. Winch
T
he winch should be kept clean of dirt, ice, paint,
etc.,andthespurgearsshouldhavealmofgrease
on them at all times. Apply several drops of SAE 30
weight oil to the ratchet pawl mechanism, bushings
and pinion shaft threads twice per season.
Replace any worn or damaged parts. For more infor-
mation on maintenance, refer to the manufacturer’s
literature included in the owner’s packet.
F. Lights
Inspect wiring for cuts or bare wire which could cause
electrical shorts. Repair or replace defective wiring.
Replace cracked or damaged lens and always carry
spare bulbs. Replacement parts may be ordered
through a Four Winns dealer.