Hisun HS 1000UTV - Check fuel line and fuel filter

Periodic Service
10-11
① First air cleaner ② Secondary air cleaner
③ Primary element ④ Cover
IMPORTANT
 The air cleaner uses a dry element never
apply oil.
 Do not run the engine with filter element
removed.
 Be sure to refit the cover with the arrow (on
the rear of cover) upright. If the cover is
improperly fitted the evacuator valve will not
function and dust will adhere to the element.
◆Evacuator Valve
Open the air cleaner cover once a week under
ordinary conditions –or daily when used in a dusty
conditions-and remove large particles of dust and
dirt.
◆Check fuel line and fuel filter.
CAUTION
To avoid personal injury:
 Be sure to stop the engine and remove the
key when attempting to make the following
checks and changes.
 Check the fuel lines periodically. The fuel
lines are subject to wear and aging fuel
may leak out onto the running engine
causing a fire.
 The fuel line connections should be
checked annually or every 100service
hours whichever comes first.
1. Park the vehicle on a flat surface and raise the
cargo bed.
2.
3. The fuel line is made of rubber and ages
regardless of service period.
4. If the fuel line and clamps are found to be
damaged or deteriorated replace them.
5. Check fuel filter if it is clogged by debris or
contaminated with water replace it.
IMPORTANT
When the fuel line is disconnected for
maintenance or repair, close both ends of the
fuel line with a piece of clean cloth or paper to
prevent dust and dirt from entering.In addition,
particular care must be taken not to allow dust
and dirt into the fuel pump entrance.Even a
small amount of dust or dirt will cause
premature wear and malfunction of the fuel
pump and injector components.
① Pipe clamp ② Fuel line
③ Fuel pump
■Checking the battery
CAUTION
To avoid personal injury
 Never remove the battery while the
engine is running.