e.
ALERT SYSTEM
These outboard motor are equipped with an alert system which protects the engine by controlling the engine speed
in the ignition control module. When trouble occurs, the system slows down the engine speed gradually. The sys-
tem is provided with indicator light and buzzer sound (remote control type only) to indicate the cause of trouble.
Warning Buzzer Sounds (Remote control type only)
open or short circuit. If it is
OK,
replace the ignition
~
Check the indicator lights.
page
2-26.
I
I
I
I
Green (oil pressure) Green (oil pressure) Red (overheat) Red (overheat)
indicator OFF indicator
ON
indicator OFF indicator ON
~.
.-
Disconnect the oil pressure switch
wire (yellow) connector and check the
indicator and buzzer.
t
Go
to page
2-23
Check the ignition control mod-
ule, replace if necessary.
If
it is
OK,
repair or replace the
OK,
test is complete.
I
~
control module.
Stop the engine
-7r
and inspect the oil Low level
-1
Add oil to the correct level.
Correct level
i
the engine and allow it
to
idle.
Check the oil pressure indicator and
buzzer.
I
Indicator OFF
I
Indicator
ON
and
buzzer stops.
Indicator
ON
and buzzer
sounds.
Indicator
ON
and
buzzer stops.
1
Check the oil pressure
(P.
2-25).
Indicator
ON
and
buzzer sounds.
Indicator OFF and
buzzer stops.
Normal
J(
i
Replace the oil pressure switch.
i
Oil strainer clogged
Oil pump faulty
Abnormal
Oil passage clogged
Oil filter cartridge clogged
2-22
To Next Page
Loading...
