14 COOLING SYSTEM 64
14.5 Refilling the coolant x
Warning
Danger of poisoning Coolant is poisonous and a health hazard.
– Coolant must not come into contact with the skin, eyes, or clothing. If contact occurs with the eyes, rinse with water imme-
diately and contact a physician. Immediately clean contaminated areas on the skin with soap and water. If coolant is swal-
lowed, contact a physician immediately. Change clothing that is contaminated with coolant. Keep coolant out of reach of
children.
700447-01
Main work
– Make sure that screw 1 is tightened.
– Stand the vehicle upright.
– Add coolant to level A.
Guideline
Level A above the radiator fins 10 mm (0.39 in)
Coolant 0.55 l (0.58 qt.) Coolant ( p. 81)
Coolant (mixed ready to use) ( p. 81)
400677-11
– Position the vehicle as shown and secure it against rolling away. A height differ-
ence of B must be reached.
Guideline
Height difference B 100 cm (39.4 in)
Info
To ensure that all of the air can escape from the cooling system, the front of
the vehicle must be jacked up. A poorly bled cooling system is less effective
at cooling and may result in overheating of the engine.
– Place the vehicle back on a level surface.
– Add coolant to level A.
– Mount the radiator cap.
– Make a short test ride.
Finishing work
– Check the coolant level. ( p. 63)
To Next Page
Loading...
