Kubota KX080-4 - Annual Servicing; Electrical Wiring and Fuses; Checking the Electrical Circuit; Checking Air-Conditioner Pipes and Hoses

REGULAR CHECKS AND MAINTENANCE WORK86
ANNUAL SERVICING
BElectrical Wiring and Fuses
Check the terminals periodically for proper connections.
Loose wiring or damaged cables can cause improper
functioning or short circuiting of the electrical system.
Check wiring and replace damaged components
immediately. If a fuse blows out soon after having been
replaced, contact your nearest KUBOTA dealer. Never
use a fuse other than specified.
BChecking the Electrical Circuit
Check the electrical circuitry for disconnections, shorts or
loose terminals.
BChecking Air-Conditioner Pipes and
Hoses
To avoid personal injury:
A Do not touch the coolant hoses or the heater
with your hand. You may get burned.
1. Check to see that all lines and hose clamps are tight
and not damaged.
2. If hoses and clamps are found worn or damaged,
replace or repair them at once. (Consult your local
KUBOTA Dealer for this service.)
BChecking Boost Sensor and AFS (Air Flow
Sensor)
Consult your local KUBOTA Dealer for this service.
BChecking Condition of Diesel Particulate
Filter (DPF) Muffler
Consult your local KUBOTA Dealer for this service.
BChecking Diesel Particulate Filter (DPF)
Differential Pressure Sensor and Piping
for Gas Leak
Consult your local KUBOTA Dealer for this service.
BChecking Diesel Particulate Filter (DPF)
Exhaust Gas Temperature Sensor
Consult your local KUBOTA Dealer for this service.
BChecking EGR Piping for Gas Leak
Consult your local KUBOTA Dealer for this service.
BIENNIAL SERVICING
To avoid personal injury:
A Do not loosen the radiator cap before the
radiator has cooled down sufficiently. Only
loosen the cap after allowing enough time for
the pressure in the system to be reduced.
Thereafter, one can remove the cap completely.
BReplacing Air-Conditioner Pipes and
Hoses
To avoid personal injury:
A Do not touch the coolant hoses or the heater
with your hand. You may get burned.
Replace air-conditioner pipes and hoses every two years.
If the hoses or pipes are swollen, hard or cracked, they
must be replaced earlier.
BReplacement of Radiator Hoses and Hose
Clamps
Replace radiator hoses and hose clamps every two years.
If the hoses are swollen, hard or cracked, they must be
replaced earlier.
(1) Radiator hoses and clamps (Both sides)