McCulloch CS 42S User Manual

TROUBLESHOOTING
TROUBLESHOOTING TABLE
a WARNING: Always stop unit and disconnect spark plug before performing all of the recommended
remedies below except remedies that require operation of the unit.
TROUBLE CAUSE REMEDY
Engine will not start or will run only
a few seconds after starting.
1. Ignition switch off.
2. (QJLQHÀRRGHG
3. Fuel tank empty.
4. 6SDUNSOXJQRW¿ULQJ
5. Fuel not reaching carburettor.
1. Move ignition switch to ON.
2. 6HH³'LI¿FXOW6WDUWLQJ´LQ
STARTING AND STOPPING
Section.
3. Fill tank with correct fuel
mixture.
4. Install new spark plug.
5. &KHFNIRUGLUW\IXHO¿OWHU
replace.
Check for kinked or split fuel
line; repair or replace.
Engine will not idle properly. 1. ,GOHVSHHGUHTXLUHV
adjustment.
2. &DUEXUHWWRUUHTXLUHV
adjustment.
1. See “Carburettor Adjustment”
in the MAINTENANCE Section.
2. Contact an authorized service
dealer.
Engine will not accelerate, lacks
power, or dies under a load.
1. $LU¿OWHUGLUW\
2. Spark plug fouled.
3. Chain brake engaged.
4. &DUEXUHWWRUUHTXLUHV
adjustment.
1. &OHDQRUUHSODFHDLU¿OWHU
2. Clean or replace plug and
regap.
3. Disengage chain brake.
4. Contact an authorized service
dealer.
Engine smokes excessively. 1. Too much oil mixed with
gasoline.
1. (PSW\IXHOWDQNDQGUH¿OOZLWK
correct fuel mixture.
Chain moves at idle speed. 1. ,GOHVSHHGUHTXLUHV
adjustment.
2. &OXWFKUHTXLUHVUHSDLU
1. See “Carburettor Adjustment”
in the MAINTENANCE Section.
2. Contact an authorized service
dealer.
18

McCulloch CS 42S Specifications

General

Chain gauge	1.3 mm
Chain pitch	3/8 \
Chain speed	20 m/s
Product color	Black, Yellow
Oil tank capacity	0.2 L
Fuel tank capacity	0.3 L
Engine displacement	42 cm³
Noise level	115 dB
Power source	Gasoline

Weight and Dimensions

Weight	4900 g