Money Control SR3 - Page 3

SR3 Type 1 Technical Manual TSP005.doc Issue 5.0 – Jan 2005
Money Controls 2005. All rights reserved.
Page 3 of 50
23. Protocols .................................................................................................................................................. 39
23.1 Serial Interface ...................................................................................................................................... 39
24. ccTalk Serial Messages.......................................................................................................................... 40
25. ccTalk Interface Circuits ......................................................................................................................... 42
25.1 Circuit 1 – ccTalk Standard Interface..................................................................................................... 42
25.2 Circuit 2 – ccTalk Low Cost Interface .................................................................................................... 43
25.3 Circuit 3 – ccTalk Direct Interface.......................................................................................................... 44
25.4 Circuit 4 – ccTalk PC Interface .............................................................................................................. 45
26. Fault Finding ............................................................................................................................................ 46
27. Service...................................................................................................................................................... 47
28. Electrical Interface Requirements.......................................................................................................... 47
29. Specified EMC Performance................................................................................................................... 48
29.1 Emissions .............................................................................................................................................. 48
29.2 Immunity ................................................................................................................................................ 48
29.3 Shock / Vibration Immunity .................................................................................................................... 48
30. Appendix A – Available Parallel Interface Looms................................................................................. 49
Tables
Table 1: SR3 Rear Cover Details. ......................................................................................................................... 10
Table 2: Parallel Interface...................................................................................................................................... 11
Table 3: Debug Features ....................................................................................................................................... 14
Table 4: DIL Switch Functions............................................................................................................................... 15
Table 5: SR3 DIL Switch Guide ............................................................................................................................. 15
Table 6: Teach and Run™ Programming - Bank 1............................................................................................... 19
Table 7: Teach and Run™ Programming - Bank 2............................................................................................... 19
Table 8: DIL Switches - Decrease Security ........................................................................................................... 22
Table 9: DIL Switches - Increase Security............................................................................................................. 22
Table 10: Sort Outputs v Sorter Paths................................................................................................................... 26
Table 11: 19 way Parallel Interface Connector ...................................................................................................... 27
Table 12: SR3 Totalising DIL Switch Guide........................................................................................................... 31
Table 13: Totalising Parameters............................................................................................................................ 36
Table 14: ccTalk Serial Commands ..................................................................................................................... 40
Table 15: Error Codes ........................................................................................................................................... 41
Table 16: Fault Codes ........................................................................................................................................... 41
Table 17: Status Codes ......................................................................................................................................... 41
Table 18: Power Supply ........................................................................................................................................ 47
Table 19: Current Consumption............................................................................................................................. 47
Table 20: Environmental Ranges .......................................................................................................................... 47
Table 21: Available Parallel Interface Looms......................................................................................................... 49