Munters MCD100E - Table of Contents

Tableofcon tents
Importantuserinformation ............... ii
Intendeduse ...........................
ii
Warranty ...............................
ii
Safety ..................................
ii
ConformitywithDirectives ............
ii
Copyright ..............................
ii
Tableofcontents ........................... iii
1 Introduction ................................. 1
1.1 General ................................
1
1.2 Aboutthismanual .....................
1
1.3 Unintendeduse ........................
1
1.4 Safetyandcautions ...................
1
1.5 Operationmonitoring .................
3
1.6 Applicationlimitations .................
3
1.7 Faultindications .......................
3
1.8 Marking ................................
4
2 Dehumidifierdesign ....................... 5
2.1 Productdescription ...................
5
2.2 Principleofoperation ..................
5
2.3 Maincomponents,explodedview ....
7
2.4 Configurationfeatures ................
8
2.4.1 Insulatedprocessairinlet .....
8
2.4.2 Processfancontrol ............
8
2.4.3 EnergyRecoveryPurge .......
9
2.5 Hightemperaturecut-out .............
9
3 Installation ................................... 10
3.1 Safety ..................................
10
3.2 General ................................
10
3.3 Inspectionofdelivery ..................
11
3.4 Movingthedehumidifier ..............
11
3.5 Storingthedehumidifier ..............
12
3.6 Siterequirements .....................
12
3.7 Splitunitinstallation ...................
12
3.7.1 Assembly .......................
14
3.7.2 Electrical connections .........
16
3.8 Ductinstallation .......................
19
3.8.1 General recommendations ...
19
3.8.2 Ductforoutdoorairinlet .......
20
3.8.3 Ductforwetairoutlet ........... 20
3.8.4 Ductconnectiondimensions for
inlets ............................
21
3.8.5 Ductconnectiondimensions for
fans .............................
22
3.9 Electricalconnections ................
23
3.10 Externalhumidity transmitter .........
24
4 Commissioning ............................. 25
4.1 Pre-startchecks .......................
25
4.2 Airflowadjustment ....................
25
4.2.1 General ......................... 25
4.2.2 Setting theratedairflows ......
26
4.2.3 Readjustingtheairflow ........
26
4.2.4 Base configurationsettings ...
27
5 Operation .................................... 28
5.1 Controlpanel ..........................
28
5.2 General ................................ 29
5.3 Safety ..................................
29
5.4 Quickstop ..............................
29
5.5 Operatingtheunit .....................
30
5.5.1 Initialstart-up,Manual mode
(MAN) ...........................
30
5.5.2 Initialstart-up,Automatic
mode(AUTO)– regulatingto
set-point ........................
30
6 Serviceandmaintenance ................. 31
6.1 Safety ..................................
31
6.2 Regularservice andmaintenance ...
31
6.3 Serviceoptions ........................
32
6.4 Extendedwarranty ....................
32
6.5 Serviceindicatorlamp ................
32
6.6 Service andmaintenanceschedule
(0–24000hours) .......................
33
6.7 Service andmaintenanceschedule
(28000–48000hours) .................
34
6.9 Airfilterreplacement ..................
35
6.9.1 Preparation .....................
35
6.9.2 Reactivationairfilter ...........
35
6.9.3 Processairfilter ................
36
7 Technicalspecification .................... 37
7.1 Capacitydiagrams ....................
37
7.2 Noisedata ............................. 38
190TEN–1065–J1408 Tableofcontents iii