B. Safety
B.7 DANGER! GASOLINE and VAPORS are FLAMMABLE and
EXPLOSIVE
• Keep multi-class ABC fire extinguishers within reach of installer and readily
available throughout the installation
• Do not smoke or permit others to smoke at or near install location
• All rags soiled with gasoline or oil must be discarded in a fire-proof container
• Routinely check for leaks and collections of gasoline pooling in install area
• Secure and shield fuel lines separately and away from electrical wiring to prevent
accidental ignition
• Keep all ignition sources away from fuel lines and including:
o
open flames
o
arc producing equipment
o
sparks
o
pilot lights
o
electrical switches
B.8 DANGER! CO POISONING and ENGINE EXHAUST INHILATION
Gasoline-powered engines and tools present a serious health hazard. They produce high
concentrations of CO and other toxic substances in their associated fumes and vapors
which, when inhaled in high concentrations, may result in death or extreme bodily injury
to the installer. CO is a poisonous, toxic, odorless, colorless and non-irritating gas, which
is given off whenever fuel or other carbon-based materials are burned.
CO can rapidly accumulate (even in areas appearing to be well ventilated), and can
overcome exposed persons without warning. Unsafe levels of CO may exist near running
gas generators or near air outflow, venting or exhaust from Generator. CO is a poisonous
gas that can cause illness, permanent neurological damage and death. Breathing CO may
produce headache, dizziness, vomiting and nausea and, in high concentrations,
unconsciousness or death. Exposure to CO at moderate to high levels, over long periods
of time, as also been linked with increased risk of heart disease.
• Review cdc.gov/niosh/topics/co/default.html for additional precautions and
recommendations regarding "Carbon Monoxide Hazards from Small Gasoline
Powered Engines"
• Read and understand the OSHA Fact Sheet and Quick Reference Sheet for Carbon
Monoxide Poisoning
https://www.osha.gov/OshDoc/data_General_Facts/carbonmonoxide-factsheet.pdf
https://www.osha.gov/Publications/3282-10N-05-English-07-18-2007.html
Page 6 of 55 Rev. 1
To Next Page