Piper Cherokee Six - Page 103

Clean
fuel
injector
inlet
line
screen
(Clean
injector
nozzles
as
required)
(Clean
with
acetone
only)
................................
Inspect
condition
of
injector
alternate
air
door
and
box
(Refer
to
the
latest
revision
of
Piper
Service
Bulletin
No.
524
and
see
Note
13)
...........................................
Inspect
intake
seals
for
leaks
and
clamps
for
tightness
..................
Inspect
all
air
inlet
duct
hoses
(Replace
as
required)
...................
Inspect
condition
of
flexible
fuel
lines
................................
Replace
flexible
fuel
lines
(See
Note
7)................................
Inspect
fuel
system
for
leaks
.........................................
Inspect
fuel
pumps
for
operation
(engine
driven
and
electric)
............
Overhaul
or
replace
fuel
pumps
(engine
driven
and
electric)
(See
Note
7).......................................................
Inspect
vacuum
pump
and
lines
.....................................
Overhaul
or
replace
vacuum
pump
(See
Note
7)
.......................
Inspect
throttle.
alternate
air,
mixture
and
propeller
governor
controls
for
security,
travel
and
operating
condition
(Refer
to
the
latest
revision
of
Piper
Service
Bulletin
No.
537)
...........
Inspect
exhaust
stacks,
connections
and
gaskets
(Refer
to
Section
III)
(Replace
gaskets
as
required)
.............................
Inspect
muffler,
heat
exchange
and
baffles
(Refer
to
Section
III)
(Refer
to
the
latest
revision
of
Piper
Service
Bulletin
No.
520)
...........
Inspect
breather
tube
for
obstructions
and
security
.....................
Inspect
crankcase
for
cracks,
leaks
and
security
of
seam
bolts
.............................................................
Inspect
engine
mounts
for
cracks
and
loose
mountings
(Refer
to
the
latest
revision
of
Piper
Service
Letter
No.
799)
...................
Inspect
all
engine
baffles
............................................
Inspect
rubber
engine
mount
bushings
for
deterioration
(Replace
as
required)
.......................................................
Inspect
fire
wall
seals
...........................................
Inspect
condition
and
tension
of
alternator
drive
belt
(Refer
to
Section
X
or
Section
XIII
if
air
conditioning
is
0
0
0
0
0
*PIPER
CHEROKEE
SIX
SERVICE
MANUAL
TABLE
III-II.
INSPECTION
REPORT
(PA-32R-300)
(cont.)
Inspection
Time
(hrs)
Nature
of
Inspection
50
100
500
1000
B.
ENGINE
GROUP
(cont.)
48.
Lubricate
alternator
idler
pulley
(if
installed);
remove
grease
seal
and
add
grease
(Refer
to
lubrication
chart
in
Service
Manual,
Section
II).....................
INSPECTION
Revised:
12/15/80
1E7